Autocar, LLC is recalling certain model year 2005-2013 ACX, WX, and WXLL trucks built November 16, 2004, through September 10, 2012. On the affected vehicles, the air brake systems were built without the required air tank drain valve. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 121, "Air Brake Systems."
Safety risk
Air tanks with valves omitted will not drain if moisture is introduced into the tank, potentially reducing air capacity in the air brake system, which could cause a reduction in brake performance and equipment durability, thus increasing the risk of a crash.
Manufacturer remedy
Autocar will notify owners, and dealers will repair the vehicles free of charge. The recall began on June 27, 2013. Owners may contact Autocar at 1-765-489-5499. Autocar's recall campaign number is A-1302.
AUTOCAR IS RECALLING 770 MY 2007-2009 WXLL HEAVY DUTY CLASS 8 VEHICLES EQUIPPED WITH RESIDENTIAL FRONT-LOADER APPLICATIONS. THESE VEHICLES MAY DEVELOP CRACKS MAINLY IN THE TOP FLANGE OF THE RH EXTENSION OF THE FRAME RAIL AT THE FRONT SPLAY BREAK WHERE THE RE-ENFORCING STRAPS ARE WELDED. DURING FRONT-LOADER OPERATION, RESIDUAL HYDRAULIC PRESSURE CAUSES THE FRONT LOADER SYSTEM TO PUSH DOWN ON THE BUMPER-MOUNTED BRACKETS, CAUSING VISIBLE DEFLECTION OF THE CHASSIS FROM THE SUSPENSION FRONT HANGER BRACKET FORWARD.
Safety risk
THE DEFLECTION MAY EVENTUALLY RESULT IN CRACKING OF THE FRAME RAIL.
Manufacturer remedy
DEALERS WILL REPLACE THE FRONT FRAME EXTENSIONS WITH THE NEW I-BEAM EXTENSION DESIGN. THE RECALL BEGAN ON SEPTEMBER 29, 2008. OWNERS MAY CONTACT AUTOCAR AT 1-765-489-5499.
CERTAIN TRUCKS FAIL TO COMPLY WITH REQUIREMENTS OF PART 568, 'VEHICLES MANUFACTURED IN TWO OR MORE STAGES, ALL INCOMPLETE, INTERMEDIATE AND FINAL-STAGE MANUFACTURERS OF VEHICLES MANUFACTURED IN TWO OR MORE STAGES.' THE GROSS VEHICLE WEIGHT RATING (GVWR) LABEL, AS APPLIED, MAY NOT BE ACCURATE. THE GVWR LABEL MAY INDICATE THAT THE VEHICLE'S LOAD CAPACITY IS HIGHER THAN THE DESIGNED WEIGHT RATING.
Safety risk
DUE TO THE ERROR IN GVWR LABELING, IT IS POSSIBLE THAT A VEHICLE COULD BE OVERLOADED WITHOUT THE VEHICLE OPERATOR'S KNOWLEDGE. A VEHICLE IN AN OVERLOADED CONDITION MAY BE SUSCEPTIBLE TO COMPONENT FAILURE THAT MAY RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
AUTOCAR WILL SEND A LETTER WHICH DESCRIBES THE DISCREPANCY IN GVWR LABELING, AND WILL INCLUDE A COMPLETE SET OF REVISED GVWR LABELS INCLUDING A REVISED INCOMPLETE VEHICLE DOCUMENT LABEL ALONG WITH INSTRUCTIONS FOR APPLICATION OF THE LABELS. THE RECALL BEGAN ON DECEMBER 7, 2007. OWNERS MAY CONTACT AUTOCAR AT 1-765-489-5499.
ON CERTAIN HEAVY DUTY CLASS 8 VEHICLES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Safety risk
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS MAY CONTACT AUTOCAR AT 765-489-5499.
ON CERTAIN HEAVY DUTY CLASS 8 XPEDITOR TRUCKS, SOME OF THE SEAT BASE MOUNTING FASTENERS THAT SECURE THE SEAT BASE TO THE CAB FLOOR BRACKET MAY HAVE BEEN LEFT LOOSE OR NOT INSTALLED AT ALL. IMPROPERLY TORQUED SEAT-MOUNTING FASTENERS MAY ALLOW MOVEMENT OF THE DRIVER'S SEAT WHILE HE/SHE IS OPERATING THE VEHICLE.
Safety risk
THIS MOVEMENT COULD RESULT IN A TEMPORARY LOSS OF CONTROL, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSPECT AND, IF NECESSARY, REPAIR THE VEHICLE. THE RECALL BEGAN ON JANUARY 22, 2007. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486, EXT. 2572 OR GO TO WWW.AUTOCARTRUCK.COM.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.