BMW of North America, LLC (BMW) is recalling certain 2000-2001 BMW 3 Series (323Ci, 325Ci, 328Ci and 330Ci), 1999-2001 323i, 328i, 330i, 330xi, and 2000 323i, 328i stationwagon vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles are equipped with driver-side air bag inflators that were previously inspected, but not replaced under recall numbers 19V-851, 19V852, or 19V-853. Due to a manufacturing issue, the NADI inflator may absorb moisture, causing the inflator to explode or the air bag cushion to underinflate.
Safety risk
The inflator could explode during air bag deployment, resulting in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Manufacturer remedy
Dealers will replace the driver-side air bag inflator with a newly designed inflator, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 1999 323i and 328i vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata at one specific inflator production facility. These inflators do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Safety risk
In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Manufacturer remedy
Dealers will inspect the driver air bag inflators and replace them, as necessary, free of charge. Owners may contact BMW customer service at 1-800-525-7417. Note: BMW recommends that owners do not continue to drive their vehicles.
BMW of North America, LLC (BMW) is recalling certain 1999-2001 323i, 325i, 328i and 330i and 2000-2001 323Ci, 325Ci, 328Ci, 330Ci, 323iT, and 325iT vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles may have received a replacement driver air bag as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Safety risk
In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Manufacturer remedy
BMW notified owners, and Dealers will replace the driver air bag inflators, free of charge. The recall began November 10, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 1999-2000 323i and 328i and 2000 323Ci and 328Ci vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These inflators do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Safety risk
In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Manufacturer remedy
BMW will mail interim notices informing owners of the safety risk on January 17, 2020. Owners will receive a second notice when the remedy becomes available. Dealers will inspect the driver air bag inflators and replace them, as necessary, free of charge. BMW mailed interim notices informing owners of the safety risk on January 17, 2020. The recall began July 27, 2020. Owners may contact BMW customer service at 1-800-525-7417.
ON CERTAIN 4-DOOR PASSENGER VEHICLES, THE SIDE AIR BAG SYSTEM COULD DEPLOY IN CERTAIN NON-CRASH IMPACTS, SUCH AS WHEN CONTACTING LARGE POTHOLES OR CURBS AT SUBSTANTIAL SPEEDS.
Safety risk
THIS COULD CAUSE THE SIDE AIR BAG AND HEAD PROTECTION SYSTEM TO DEPLOY WITHOUT AN ACTUAL SIDE CRASH OR IMPACT SEVERE ENOUGH TO CAUSE SIGNIFICANT VISIBLE DAMAGE TO THE VEHICLE. UNEXPECTED DEPLOYMENT OF THE SIDE AIR BAG COULD CAUSE SERIOUS INJURY IF THE OCCUPANT'S HEAD IS RESTING NEAR THE SIDE AIR BAG.
Manufacturer remedy
DEALERS WILL RECALIBRATE THE CENTRAL AIR BAG CONTROL MODULE TO REDUCE THE POSSIBILITY OF SUCH A NON-CRASH DEPLOYMENT. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IT IS POSSIBLE THAT THE RETAINING CLIP THAT SECURES THE BRAKE BOOSTER PUSHROD TO THE BRAKE PEDAL ARM WAS NOT PROPERLY INSTALLED DURING PRODUCTION. IT IS POSSIBLE FOR THE CLIP TO DETACH FROM THE PIN ON THE BRAKE PEDAL ARM ALLOWING THE PUSHROD TO DISCONNECT FROM THE ARM.
Safety risk
IF THIS OCCURS, BRAKING IS NOT POSSIBLE.
Manufacturer remedy
DEALERS WILL INSPECT THE CLIP FOR TIGHT INSTALLATION AND REPLACE THE CLIP IF IT IS LOOSE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES ARE BUILT WITH A SIDE AIR BAG SYSTEM CONSISTING OF DOOR-MOUNTED THORAX AIR BAGS (REAR DOOR AIR BAGS ARE OPTIONAL), A HEAD PROTECTION SYSTEM (HPS) FOR FRONT OCCUPANTS, A CENTRAL ELECTRONIC SENSOR AND DIAGNOSTIC SYSTEM, LEFT AND RIGHT SATELLITE IMPACT SENSORS, AND ASSOCIATED WIRING. THIS SYSTEM IS UNDULY SENSITIVE TO CERTAIN NON-CRASH IMPACTS, SUCH AS CONTACTING LARGE POTHOLES OR CURBS AT SUBSTANTIAL SPEED.
Safety risk
THIS COULD CAUSE THE SIDE AIR BAG AND HPS TO DEPLOY WITHOUT AN ACTUAL SIDE CRASH. IN ADDITION, THE BATTERY SAFETY TERMINAL (BST) WOULD ALSO ACTIVATE, DISCONNECTING THE STARTER CABLE FROM THE BATTERY. IN THIS CASE, VEHICLE ELECTRICAL SYSTEM WOULD CONTINUE TO OPERATE AND THE ENGINE WOULD CONTINUE TO RUN, BUT AFTER STOPPING, COULD NOT BE RESTARTED.
Manufacturer remedy
DEALERS WILL REPROGRAM THE CENTRAL COMPUTER CONTROL MODULE THAT REGULATES THE PERFORMANCE OF ALL OF THE VEHICLE'S OCCUPANT PROTECTION SYSTEMS.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Air bags
27
110,000 mi
Air bags: frontal
10
—
Structure: frame and members
8
65,000 mi
Electrical system
6
61,000 mi
Power train: automatic transmission
6
130,000 mi
Air bags: side/window
5
90,000 mi
Suspension: rear
4
107,800 mi
Latches/locks/linkages
3
150,000 mi
Power train: driveline: differential unit
3
40,000 mi
Tires
3
—
Vehicle speed control
3
45,000 mi
Visibility: power window devices and controls
3
62,407 mi
Wheels
3
—
Power train
2
137,520 mi
Seat belts: front: buckle assembly
2
49,891 mi
Service brakes, hydraulic
2
12,000 mi
Service brakes, hydraulic: antilock/traction control/electronic limited slip
2
30,000 mi
Service brakes, hydraulic: pedals and linkages
2
105,000 mi
Structure: body
2
122,000 mi
Suspension
2
135,000 mi
Suspension: front
2
49,545 mi
Tires: sidewall
2
—
Tires: tread/belt
2
—
Electrical system: wiring: front underhood
1
—
Electronic stability control (ESC)
1
175,000 mi
Engine and engine cooling: engine: gasoline
1
—
Exterior lighting
1
25,000 mi
Exterior lighting: brake lights
1
—
Fuel/propulsion system
1
203,000 mi
Power train: clutch assembly
1
—
Power train: driveline: driveshaft
1
—
Seat belts
1
150,000 mi
Seat belts: front
1
62,407 mi
Seat belts: front: retractor
1
—
Seats
1
108,000 mi
Service brakes, hydraulic: foundation components
1
—
Service brakes, hydraulic: foundation components: disc
1
—
Service brakes, hydraulic: foundation components: disc: rotor
1
—
Steering: column locking: anti-theft device
1
—
Structure
1
65,000 mi
Suspension: front: control arm: lower arm
1
—
Suspension: rear: springs
1
91,000 mi
Traction control system
1
175,000 mi
Unknown or other
1
—
The 1998 model has 4 times as many complaints as this one. The 2000 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.