Fuel system, gasoline: storage: tank assembly: filler pipe and cap
Manufacturer
Bombardier Recreational Products Inc.
Vehicles affected
33,700
Reported to NHTSA
2012-12-12
Owners notified
2012-12-21
Defect description
Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2012 Can-Am Spyder GS, RS, and RT series vehicles. The fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.
Safety risk
If the fuel cap does not seal properly, it may leak fuel vapors. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.
Manufacturer remedy
BRP will notify owners and send them a replacement fuel cap, free of charge. The safety recall is expected to begin in mid-January 2013. Owners may contact BRP AT 1-888-638-5397.
BOMBARDIER RECREATIONAL PRODUCTS INC. (BRP) IS RECALLING CERTAIN MODEL YEAR 2010 SPYDER RT ROADSTERS. A PIN SECURING THE BRAKE PEDAL CONNECTING ROD COULD DISENGAGE AND FALL OFF.
Safety risk
IF THIS OCCURS, A TOTAL LOSS OF MAIN BRAKE FUNCTION COULD RESULT WITHOUT PRIOR WARNING. THERE IS AN INCREASED RISK OF A CRASH POSSIBLY RESULTING IN INJURY OR DEATH.
Manufacturer remedy
BRP WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE BRAKE PEDAL CONNECTING ROD PINS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 18, 2012. OWNERS MAY CONTACT BRP AT 1-888-638-5397.
BRP IS RECALLING CERTAIN MODEL YEAR 2010 SPYDER RS SE5 2ND SERIES AND RT SE5 ROADSTERS. WHEN BRINGING A VEHICLE EQUIPPED WITH THE SE5 SEMI-AUTOMATIC TRANSMISSION TO A FULL STOP, THE CLUTCH MAY REMAIN ENGAGED STALLING THE ENGINE. ONCE THE ENGINE IS STALLED, IT COULD BE IMPOSSIBLE TO RE-START AND THE REAR WHEEL COULD BE BLOCKED.
Safety risk
IF THIS HAPPENS, THE VEHICLE MAY NOT BE ABLE TO BE PUSHED OFF THE ROADWAY INCREASING THE RISK OF A CRASH.
Manufacturer remedy
BRP WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 7, 2010. OWNERS MAY CONTACT BRP AT 1-888-638-5397.
BOMBARDIER RECREATIONAL PRODUCTS, INC. (BRP) IS RECALLING MODEL YEAR 2010 ROADSTER SPYDER RT SM5 AND SE5 MOTORCYCLES MANUFACTURED BETWEEN OCTOBER 13 AND OCTOBER 30, 2009. THE CONNECTOR ON THE KEY SWITCH HARNESS MAY NOT BE LOCKED AND THE IGNITION SWITCH HARNESS MAY BE ROUTED TOO TIGHT. IN SOME SITUATIONS, THE CONNECTOR MAY UNPLUG.
Safety risk
IF THIS OCCURS, THE VEHICLE MAY STALL WITHOUT WARNING AND COULD POTENTIALLY CAUSE A CRASH.
Manufacturer remedy
BRP WILL NOTIFY OWNERS AND AUTHORIZED DEALERS WILL INSPECT TO ENSURE THAT THE CONNECTOR IS LOCKED AND THAT THE IGNITION SWITCH HARNESS IS NOT ROUTED TOO TIGHT AND CORRECT THE HARNESS IF NEEDED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 18, 2009. OWNERS MAY CONTACT BRP AT 1-888-638-5397 OR 1-819-566-3366.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Steering
8
15,000 mi
Engine and engine cooling
3
2,800 mi
Engine
2
—
Fuel/propulsion system
2
500 mi
Power train
2
100 mi
Power train: automatic transmission
2
610 mi
Power train: clutch assembly
2
5 mi
Service brakes, hydraulic
2
—
Air bags
1
15,000 mi
Electronic stability control (ESC)
1
—
Exterior lighting
1
—
Exterior lighting: turn signal
1
—
Exterior lighting: turn signal: switch
1
—
Service brakes
1
4,626 mi
Service brakes, air: controls: foot control/valve
1
6,700 mi
Suspension
1
15,000 mi
The 2009 model has 31 times as many complaints as this one. The 2011 model has about half as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.