CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS INSTALLED BETWEEN MAY 2006 AND JUNE 2009. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT WHICH CONTAINS A RELAY BOARD AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT.
Safety risk
AN ELECTRICAL FAILURE IN THE RELAY BOARD, CAN CAUSE OVERHEATING AND POSE A SERIOUS FIRE HAZARD.
Manufacturer remedy
TRANS AIR WILL NOTIFY THE OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. PLEASE ALSO SEE TRANS/AIR DEFECT REPORT 09E-042. THE SAFETY RECALL BEGAN ON MAY 19, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE DEPARTMENT AT 1-800-673- 2446.
GENERAL COACH IS RECALLING CERTAIN MODEL YEAR 2005-2006 LO-TRANS, MODEL YEAR 2007 EZ-TRANS AND MODEL YEAR 2009-2010 IC-LC BUSES BUILT ON INTERNATIONAL 3200IM CHASSIS MANUFACTURED FROM JULY 2003 THROUGH FEBRUARY 2010. WHEN THE BUSES ARE USED IN A SEVERE DUTY APPLICATION, SUCH AS BUSES IN HEAVY TRANSIT USE, THERE CAN BE OVERHEATING OF THE BRAKES.
Safety risk
IF THE OVERHEATING BECOMES EXCESSIVE, IT COULD RESULT IN A FIRE LOCATED AT THE BRAKE AREA. A FIRE MAY RESULT IN PERSONAL INJURY, PROPERTY DAMAGE, OR DEATH.
Manufacturer remedy
GENERAL COACH IS WORKING WITH INTERNATIONAL TO DEFINE THE REMEDY FOR THIS CAMPAIGN. THE BUSES WILL BE RETROFITTED WITH AN AFTERMARKET TRANSMISSION RETARDER THAT WILL LOWER THE TEMPERATURES OF THE BRAKING COMPONENTS DOWN INTO THE NORMAL OPERATING RANGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGED. THE RECALL BEGAN ON MAY 10, 2010. OWNERS MAY CONTACT GENERAL COACH AT 1-800-842-0622.
CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Safety risk
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Manufacturer remedy
CHAMPION BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR CHAMPION BUS AT 1-800-331-5761.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.