Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
Manufacturer
GENERAL MOTORS LLC
Vehicles affected
7,593
Reported to NHTSA
2011-05-06
Owners notified
2011-05-13
Defect description
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A CLEARANCE CONDITION IN WHICH THE RIGHT REAR BRAKE HOSE MAY CONTACT THE TIRE OR WHEEL RIM. IF THE BRAKE HOSE REPEATEDLY CONTACTS THE TIRE OR WHEEL RIM, A HOLE COULD BE WORN IN THE BRAKE HOSE.
Safety risk
A DAMAGED BRAKE HOSE MAY REDUCE THE EFFECTIVENESS OF THE REAR BRAKES AND INCREASE THE DISTANCE REQUIRED TO STOP THE VEHICLE. AN INCREASED BRAKING DISTANCE MAY INCREASE THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL SECURE THE RIGHT REAR BRAKE HOSE TO ENSURE SUFFICIENT CLEARANCE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Safety risk
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Manufacturer remedy
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Air bags
1
80,000 mi
Exterior lighting
1
12,000 mi
Service brakes
1
87,000 mi
The 2010 model has about half as many complaints as this one. The 2012 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.