Eldorado National-California, Inc. (Eldorado) is recalling certain model year 2007-2015 Axess, E-Z Rider II, and XHF vehicles manufactured July 1, 2007, to May 2, 2015, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Safety risk
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Manufacturer remedy
Cummins has notified owners on behalf of Eldorado, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 16, 2015. Owners may contact Eldorado customer service at 1-909-591-9557 or Cummins customer service at 1-800-343-7357.
Eldorado National (California), Inc. (Eldorado) is recalling certain model year 2005-2012 Axess, 2006-2013 E-Z Rider II and 2013 Passport buses equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Safety risk
Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Manufacturer remedy
Eldorado will notify owners, and dealers will replace the equalizers or converters, free of charge. The recall began on February 15, 2014. Owners may contact Eldorado at 1-909-591-9557. Eldorado's number for this recall is EQ-14-002.
ELDORADO NATIONAL IS RECALLING CERTAIN MODEL YEAR 2002-2010 TRANSIT BUSES, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Safety risk
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Manufacturer remedy
ELDORADO NATIONAL WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR ELDORADO NATIONAL AT 1-909-591-9557.
ELDORADO NATIONAL - CALIFORNIA (ENC) IS RECALLING 106 MY 2004-2007 AXESS, E-Z RIDER II AND TRANSMARK RE REAR ENGINE BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES AND EQUIPPED WITH THE CM850 FUEL SYSTEM. THE ENGINE HIGH PRESSURE FUEL LINES FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL ARE PRONE TO FAILURE. THE FUEL LINE FAILURES HAVE BEEN DETERMINED TO BE CAUSED BY PROLONGED VIBRATION. FAILURE TYPICALLY OCCURS AT OR UNDER THE FUEL LINE FITTING ATTACHMENTS. FAILURE OF THE FUEL LINE INTRODUCES HIGH PRESSURE ATOMIZED DIESEL FUEL INTO THE ENGINE COMPARTMENT.
Safety risk
FUEL INTO THE ENGINE COMPARTMENT CREATES A RISK OF FIRE DUE TO POSSIBLE IGNITION WHEN THE FUEL VAPOR COMES IN CONTACT WITH HOT SURFACES.
Manufacturer remedy
ENC WILL WORK WITH CUMMINS TO INSTALL A SUPPORT BRACKET ON THE HIGH PRESSURE FUEL LINES FREE OF CHARGE. THE RECALLBEGAN ON MARCH 11, 2008. OWNERS MAY CONTACT ELDORADO NATIONAL - CALIFORNIA AT 909-591-9557.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.