FLEETWOOD IS RECALLING 311 MY 2008-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOUNDER DIESEL MOTOR HOME. THE BATTERY CABLE MAY BECOME DISLODGED AND COME IN CONTACT WITH THE DRIVER SHAFT CAUSING ENTANGLEMENT OR ABRASION TO THE BATTERY CABLE.
Safety risk
THIS COULD LEAD TO AN ELECTRICAL SHORT WHICH MAY RESULT IN A FIRE OR UN-COMMANDED VEHICLE SHUTDOWN WHICH MAY RESULT IN A LOSS OF VEHICLE CONTROL.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE DAMAGE BATTERY CABLES AND SECURE THE BATTERY CABLE HARNESS ABOVE THE DRIVE SHAFT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Safety risk
THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Manufacturer remedy
DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.
Safety risk
OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 28, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.
Safety risk
IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.
Manufacturer remedy
DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.
ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.
Safety risk
OVERHEATING OF THE INVERTER MAY RESULT IN A POTENTIAL FIRE.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE THE INVERTER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 19, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Safety risk
INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Manufacturer remedy
THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Engine and engine cooling: exhaust system
1
1,500 mi
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.