FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
Safety risk
IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Manufacturer remedy
FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Safety risk
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Manufacturer remedy
FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
ON CERTAIN MOTOR HOMES, THE ELECTRIC POWER FOR THE ENTRY DOORSTEP "LAST OUT" FEATURE HAS NOT BEEN PROVIDED AND THE ENTRY DOORSTEP WILL NOT OPERATE IN "LAST OUT" MODE. THE "LAST OUT" IS A SAFETY FEATURE THAT CAUSES THE ENTRY DOORSTEP TO EXTEND ONE LAST TIME IF THE ENTRY DOORSTEP POWER SWITCH IS OFF AND THE VEHICLE IGNITION IS TURNED OFF.
Manufacturer remedy
DEALERS WILL INSPECT AND PROVIDE POWER SO THE ENTRY DOORSTEP "LAST OUT" FEATURE IS ACTIVE. OWNER NOTIFICATION BEGAN SEPTEMBER 10, 2003. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
THESE MOTOR HOMES ARE WIRED IN SUCH A MANNER THAT THE VEHICLE OPERATOR MUST ENSURE THAT THE BATTERY DISCONNECT SWITCH IS IN THE "USE" POSITION TO ACTIVATE REAR CAP TAIL LAMPS, STOP LAMPS, BACKUP LAMPS, TURN SIGNAL LAMPS, AND CLEARANCE LAMPS.
Safety risk
OPERATION OF THE MOTOR HOME WITHOUT THESE LAMPS MAKES THE MOTOR HOME LESS VISIBLE AND DOES NOT SIGNAL TURN, BACKUP, OR BRAKING ACTIONS OF THE MOTOR HOME, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REWIRE THE MOTOR HOME SO THAT THE AFFECTED REAR CAP LAMPS REMAIN ENERGIZED WHENEVER THE CHASSIS ENGINE IS RUNNING. OWNER NOTIFICATION BEGAN MARCH 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
VEHICLE DESCRIPTION: CERTAIN CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MOTOR HOMES WERE NOT EQUIPPED WITH RED REFLEX REFLECTORS ON THE REAR AND RED REFLEX REFLECTORS/SIDE MARKER LAMPS ON THE SIDE AS FAR TO THE REAR AS PRACTICABLE.
Safety risk
AT NIGHT, WITHOUT THIS REFLECTOR INSTALLED, THE APPROACHING DRIVER MAY NOT BE AWARE THAT THE VEHICLE IS AHEAD, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSTALL THE REFLECTORS TO THE REAR AND SIDE OF THE MOTOR HOME. OWNER NOTIFICATION BEGAN NOVEMBER 16, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.