ON CERTAIN MOTORCYCLES, THE WELD ATTACHING THE FENDER MOUNT TO THE FRONT FORK MAY CRACK AND BREAK.
Safety risk
THIS COULD CAUSE THE FENDER MOUNT TO FAIL RESULTING IN THE FENDER COMING INTO CONTACT WITH THE WHEEL, RESULTING IN THE RIDER TO LOSE CONTROL OF THE MOTORCYCLE, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL BOLT A BRACKET ONTO EACH FRONT FORK. THIS BRACKET WILL HOLD THE FENDER MOUNT IN PLACE EVEN IF THE WELD FAILS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST 2003. OWNERS SHOULD CONTACT INDIAN AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES, THE BRACKET USED TO SUPPORT THE TEARDROP HEADLIGHT CAN CRACK, CAUSING THE BRACKET TO BREAK AND THE LIGHT TO SLIP OUT OF POSITION OR FALL OFF.
Safety risk
THIS COULD CAUSE A LOSS OF VISIBILITY TO THE DRIVER, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSTALL A NEW BRACKET. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST 2003. OWNERS SHOULD CONTACT IMC AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES, DUE TO THE POSITIONING OF THE GAS TANK VENT TUBE, THE VENT TUBE CAN BECOME CLOGGED WITH DEBRIS, PARTICULARLY IN WET WEATHER. VENT TUBE CLOGGING CAN CAUSE INTERRUPTION OF FUEL FLOW TO THE CARBURETOR, CAUSING THE ENGINE TO STOP. A CLOGGED VENT TUBE MAY ALSO CAUSE PRESSURE TO BUILD UP IN THE GAS TANK AND PUSH A SMALL AMOUNT OF GAS OUT OF THE FUEL FILLER CAP SEAL.
Safety risk
FUEL LEAKAGE IN THE PRESENT OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Manufacturer remedy
DEALERS WILL REPLACE THE CURRENT VENT TUBE WITH A LONGER TUBE REPOSITIONED TO PREVENT CLOGGING. OWNER NOTIFICATION BEGAN APRIL 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES, THE FASTENERS THAT BOLT THE WINDSHIELD TO THE MOUNTING CLAMPS CAN BREAK, CAUSING THE WINDSHIELD TO COME PARTIALLY OR COMPLETELY OFF THE BIKE.
Safety risk
IF THIS HAPPENS WHILE THE MOTORCYCLE IS IN USE, THE RIDER COULD BE INJURED BY THE WINDSHIELD.
Manufacturer remedy
DEALERS WILL REPLACE THE WINDSHIELDS. OWNER NOTIFICATION BEGAN JANUARY 16, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES, THE REAR AXLES ARE MADE OF A MATERIAL WITH A LOWER THAN DESIRABLE YIELD STRENGTH.
Safety risk
UNDER REPEATED HEAVY LOADS, THE REAR AXLE COULD DEFORM CAUSING EXCESSIVE WEAR IN THE REAR WHEEL BEARINGS POTENTIALLY LEADING TO OVERHEATING AND SEIZING OF THE BEARINGS, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE REAR AXLES ON THESE MOTORCYCLES. OWNER NOTIFICATION BEGAN AUGUST 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN AT 1-408-846-7228.
ON CERTAIN MOTORCYCLES, FRACTURES CAN OCCUR ON EITHER THE LEFT OR RIGHT FUEL TANK AT THE TOP OF THE JOINT WHERE THE BRACKET IS WELDED TO THE TANK BACK PLATE.
Safety risk
FUEL CAN ESCAPE FROM THE TANK, INCREASING THE RISK OF A FIRE.
Manufacturer remedy
DEALERS WILL REPLACE THE GAS TANKS WITH TANKS THAT HAVE A REDESIGNED MOUNTING BRACKET. OWNER NOTIFICATION BEGAN MARCH 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-408-846-7228.
SOME MOTORCYCLES MAY HAVE A GAS TANK VENTING SYSTEM THAT BECAME CLOGGED DURING PRODUCTION.
Safety risk
THIS CLOGGING PREVENTS THE VENTING SYSTEM FROM ALLOWING PRESSURE TO ESCAPE FROM THE GAS TANK, WHICH COULD RESULT IN GAS FLOWING BACK INTO THE CARBURETOR AND POSSIBLY SPILLING ONTO THE GROUND.
Manufacturer remedy
ALL MOTORCYCLES HAVE BEEN INSPECTED AND, IF NECESSARY, CORRECTED. THIS CAMPAIGN IS 100% COMPLETED.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Service brakes, hydraulic: foundation components: master cylinder
1
—
Suspension: rear: shock absorber
1
5,800 mi
The 2001 model has roughly the same number of complaints as this one. The 2003 model has 4 times as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.