International Motors, LLC (International) is recalling certain 2024 HV, 2020-2025 MV, and 2019 Workstar 7400 trucks. The caliper may contact a suspension spring or axle U-bolt and prevent the outer brake pad from functioning.
Safety risk
A loss of outer brake pad function can extend the vehicle's stopping distance, increasing the risk of a crash.
Manufacturer remedy
Dealers will switch the left and right rear air disc brake calipers, replace the rear brake torque plates, and replace the brake pads, free of charge. Owner notification letters were mailed May 12, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25501.
International Motors, LLC (International) is recalling certain 2021-2024 Lonestar, 2021-2025 RH, HV, MV, LT, HX, and 2022 PROSTAR vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Safety risk
Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.
Manufacturer remedy
International will work with Bendix to reprogram the ECU software, free of charge. Owner notification letters were mailed December 16, 2024. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 24515.
Navistar, Inc. (Navistar) is recalling certain 2024 International HX, LT, RH and 2024-2025 International HV, MV trucks and 2024 IC Bus CE commercial buses. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
Safety risk
A loss of steering control increases the risk of a crash.
Manufacturer remedy
Dealers will inspect and replace the defective gears, free of charge. Owner notification letters were mailed September 30, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 24503.
Navistar, Inc. (Navistar) is recalling certain 2024 International HV and International MV trucks. The driver's seat belt tether bolt may not be properly seated in the anchor, causing a bind at the anchor point.
Safety risk
An improperly anchored seat belt tether may not restrain an occupant as intended, increasing their risk of injury during a crash.
Manufacturer remedy
Dealers will inspect and replace the seat belts as necessary, free of charge. Owner notification letters were mailed February 26, 2024. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 24501.
Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Safety risk
An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.
Manufacturer remedy
Towing variant vehicles under this campaign will not be repaired under recall 24V-8918. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23515.
Engine and engine cooling: engine: engine control module (ECU/ECM): software
Manufacturer
Navistar, Inc.
Vehicles affected
27,972
Reported to NHTSA
2023-02-23
Owners notified
2023-04-24
Defect description
Navistar, Inc. (Navistar) is recalling certain 2022-2024 International HV, International MV trucks, and 2022-2023 IC Bus TC commercial buses. When the parking brake is applied, the automatic transmission is still in drive or reverse position, and the stationary power take-off (PTO) switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.
Safety risk
Unexpected vehicle movement can increase the risk of a crash or injury.
Manufacturer remedy
Dealers will update the Cummins ECM software, free of charge. Owner notification letters are expected to be mailed April 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23504. This recall expands previous NHTSA recall number 20V-810.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.