Engine and engine cooling: engine: gasoline: belts and associated pulleys
Manufacturer
Mitsubishi Motors North America, Inc.
Vehicles affected
165,923
Reported to NHTSA
2014-09-12
Owners notified
2014-10-15
Defect description
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2011 Lancer, Lancer Evolution, and Outlander; 2009-2011 Lancer Sportback, Lancer Rilliart, and Lancer Sportback Ralliart; and 2011 Outlander Sport vehicles. The affected vehicles, manufactured with 4B1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). These pulleys may experience unusual wear and allow for belt detachment.
Safety risk
If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.
Manufacturer remedy
Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. Drive pulleys that are excessively worn will be replaced. These repairs will be performed free of charge. The recall began on October 15, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-009.
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2013 Lancer Evolution vehicles manufactured from December 12, 2007, through March 5, 2013. In the affected vehicles, the clutch master cylinder can fail.
Safety risk
Failure of the clutch master cylinder reduces the ability to shift the vehicle into or out of gear, increasing the risk of a crash.
Manufacturer remedy
Mitsubishi will notify owners, and dealers will replace the affected clutch master cylinders free of charge. The recall began on November 12, 2013. Owners may contact Mitsubishi at 1-888-648-7820. Mitsubishi's campaign number for this recall is SR-13-009.
MITSUBISHI IS RECALLING MODEL YEAR 2008-2009 LANCER AND LANCER EVOLUTION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND DISTRICT OF COLUMBIA. IN AREAS WHERE HEAVY ROAD SALT IS USED IN THE WINTER, A LONG TERM EXPOSURE TO A MIXTURE OF MELTED SNOW WITH SALT THROWN UP BY THE OTHER VEHICLES ON THE ROAD MAY CAUSE A WATER-SALT MIXTURE TO ADHERE TO THE FRONT IMPACT SENSORS.
Safety risk
THIS COATING OVER TIME MAY CAUSE CORROSION OF THE SENSOR. IN THE EVENT OF A VEHICLE CRASH OF THE TYPE THAT WOULD DEPLOY THE AIRBAGS THIS TYPE OF SHORT-CIRCUIT MAY CAUSE A DELAY IN THE DEPLOYMENT OF THE AIRBAGS WHICH COULD RESULT IN DRIVER OR PASSENGER INJURY.
Manufacturer remedy
DEALERS WILL INSTALL NEW FRONT AIRBAG SENSORS THAT HAVE IMPROVED CORROSION RESISTANCE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 27, 2009. OWNERS MAY CONTACT MITSUBISHI CUSTOMER RELATIONS DEPARTMENT AT 1-888-648-7820.
MITSUBISHI IS RECALLING MODEL YEAR 2008-2009 LANCER EVOLUTION, RALLIART, AND SPORTBACK RALLIART VEHICLES EQUIPPED WITH TURBOCHARGED ENGINES. THE MANNER IN WHICH THE FUEL RETURN PIPE IS ATTACHED TO THE ENGINE, IN COMBINATION WITH FREQUENT VEHICLE OPERATION AT CERTAIN ENGINE REVOLUTIONS, MAY RESULT IN A RESONANCE THAT, IF CONTINUED OVER TIME, MAY CAUSE A STRESS CRACK TO DEVELOP AT THE FIXED PORTION OF THE FUEL PIPE.
Safety risk
IF THIS STRESS CRACK DEVELOPS, FUEL LEAKAGE MAY OCCUR. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Manufacturer remedy
THE FUEL RETURN PIPE WILL BE REPLACED WITH A NEW PART AND TWO ADDITIONAL ATTACHMENT BRACKETS WILL BE INSTALLED TO BETTER CONTROL FUEL PIPE VIBRATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 29, 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Power train
26
47,850 mi
Electronic stability control (ESC)
19
47,850 mi
Fuel system, gasoline
3
35,000 mi
Equipment adaptive/mobility
2
40,000 mi
Engine and engine cooling
1
53,500 mi
Seats
1
4,400 mi
Structure: body
1
4,400 mi
Suspension
1
29,700 mi
Tires
1
39,000 mi
Unknown or other
1
—
Vehicle speed control
1
10,000 mi
The 2009 model has 29 times as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.