MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Safety risk
EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Manufacturer remedy
MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
ON CERTAIN CLASS A MOTOR H0MES BUILT WITH GASOLINE ENGINES, THE FRAME EXTENSION LOWER FLANGE MAY CRACK ALLOWING THE HITCH TO BEND AND POSSIBLY SEPARATE FROM THE MOTOR HOME.
Safety risk
THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE.
Manufacturer remedy
DEALERS WILL ADD AN ADDITION OF TWO PIECES OF ANGLE STEEL TO THE FRAME EXTENSION AND HITCH MOUNTING POINT IN ORDER TO REINFORCE THE FRAME EXTENSION FLANGE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 15, 2007. OWNERS MAY CONTACT MONACO AT 877-466-6226. NOTE: THE ENDING MANUFACTURING DATE FOR INDIANA BUILT MOTOR HOMES IS MARCH 8, 2002 WHILE THE OREGON BUILT MOTOR HOMES WERE BUILT THROUGH NOVEMBER 2002. THE FEDERAL ID LABEL LOCATED ON THE WALL NEXT TO THE DRIVER'S SEAT SPECIFIES IN WHICH STATE THE MOTOR HOME WAS BUILT.
Service brakes, hydraulic: brake fluid low warning: lamp
Manufacturer
MONACO COACH CORP.
Vehicles affected
5,361
Reported to NHTSA
2003-03-05
Owners notified
2003-05-07
Defect description
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Safety risk
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Manufacturer remedy
DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MAY 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO COACH AT 1-877-477-6226.
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Safety risk
THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Manufacturer remedy
DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN CLASS A MOTOR HOMES, THE FLOOR TRUSS NETWORK SUPPORT SYSTEM HAS A POTENTIAL TO WEAKEN CAUSING INTERNAL AND EXTERNAL FEATURES TO BECOME MISALIGNED. THE AFFECTED VEHICLES ARE 1999 - 2003 CLASS A MOTOR HOMES MANUFACTURED ON F53 20,500 POUND GROSS VEHICLE WEIGHT RATING (GVWR), FORD CHASSIS, AND 2000-2003 CLASS A MOTOR HOMES MANUFACTURED ON W-22 22,000 POUND GVWR, WORKHORSE CHASSIS.
Safety risk
CONDITIONS CAN RESULT IN THE BOTTOMING OUT THE SUSPENSION AND AMPLIFICATION OF THE STRESS PLACED ON THE FLOOR TRUSS NETWORK. THE ADDITIONAL STRESS CAN RESULT IN THE FRACTURE OF WELDS SECURING THE FLOOR TRUSS NETWORK SYSTEM TO THE CHASSIS FRAME RAIL AND/OR FRACTURE OF THE FLOOR TRUSS NETWORK SUPPORT SYSTEM. THE POSSIBILITY EXISTS THAT THERE COULD BE DAMAGE TO ELECTRICAL WIRING AND/OR FUEL LINES WHICH COULD POTENTIALLY LEAD TO A FIRE.
Manufacturer remedy
DEALERS WILL INSPECT THE FLOOR TRUSS NETWORK SUPPORT SYSTEM, REINFORCE THE EXISTING STRUCTURE, AND REPAIR, AS NEEDED, THE FLOOR TRUSS NETWORK SUPPORT. OWNER NOTIFICATION BEGAN NOVEMBER 5, 2002. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
Manufacturer
MONACO COACH CORP.
Vehicles affected
251
Reported to NHTSA
2001-08-15
Owners notified
2001-09-05
Defect description
VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON WORKHORSE CHASSIS. SPECIFIC FLOOR PLANS AT ISSUE ARE 30D, 30PBD, 32PBD, 36DPD, 36PBD, 36WDD, AND 37WDD. THE SUPPLY AND RETURN LINE CARRYING GASOLINE TO AND FROM THE ENGINE, MAY HAVE BEEN IMPROPERLY ROUTED AND/OR SECURED ON YOUR WORKHORSE GASOLINE CHASSIS.
Safety risk
AS A RESULT, THE FUEL LINE COULD BECOME DAMAGE, AND INTRODUCE THE RISK OF A FIRE.
Manufacturer remedy
DEALERS WILL INSPECT THE FUEL LINE ROUTING, INSTALL ADDITIONAL MEANS OF SECURING THE FUEL LINE, IF REQUIRED, AND/OR REPLACE THE LINE IF DAMAGE HAS OCCURRED. OWNER NOTIFICATION BEGAN SEPTEMBER 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Safety risk
SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Manufacturer remedy
DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. AM-SAFE IS CONDUCTING THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 219-266-8330 OR MONACO AT 219-862-7211.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Equipment: recreational vehicle/trailer: LPG systems: tank assembly
1
28,000 mi
Structure: frame and members: underbody shields
1
—
Suspension: front: springs: air suspension: springs/bags
1
—
Suspension: rear
1
—
Suspension: rear: springs: air suspension system: springs/bags
1
—
Suspension: rear: springs: leaf spring assembly
1
25,000 mi
The 2000 model has 2 times as many complaints as this one. The 2002 model has about half as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.