Service brakes, air: supply: hoses, lines/piping, and fittings
Manufacturer
INTERNATIONAL TRUCK AND ENGINE
Vehicles affected
277
Reported to NHTSA
1999-11-23
Owners notified
1999-12-01
Defect description
VEHICLE DESCRIPTION: SCHOOL BUS. AN AIR BRAKE LINE CONTROLLING THE REAR BRAKES MAY BE TOO CLOSE TO THE EXHAUST PIPE AND COULD RUPTURE AT ANY TIME WITHOUT WARNING.
Safety risk
EXHAUST PIPE HEAT CAN MELT OR CAUSE PREMATURE FAILURE OF THIS AIR LINE IF THE AIR LINE IS ROUTED TOO CLOSE TO THE EXHAUST PIPE.
Manufacturer remedy
DEALERS WILL INSTALL A NEW ELBOW FITTING AND REROUTE THE AIR LINE. THE AIR LINE WILL ALSO BE INSPECTED AND REPLACED IF FOUND TO BE DAMAGED FROM THE EXHAUST PIPE.
VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES BUILT WITH ABS AIR BRAKE ECU AND A 100 GALLON FUEL TANK MOUNTED BETWEEN THE RAILS AND BEHIND THE REAR AXLE ON MODELS WITH A 276" WHEEL BASE. THE ABS ECU INTERFERED WITH THE CROSS MEMBER MOUNTED BEHIND THE REAR AXLE AND IN FRONT OF THE BETWEEN THE RAILS FUEL TANK. THIS CREATED A NO-BUILD SITUATION AT THE PLANT - THE PLANT WOULD EITHER ELIMINATE OR RELOCATE THE CROSS MEMBER OR MOVE THE ECU AS NEEDED.
Safety risk
IF THE CROSS MEMBER IS EITHER MISSING OR RELOCATED THE VEHICLE MAY NOT HAVE ADEQUATE FUEL TANK PROTECTION. IN THE EVENT OF A CRASH, THE BUS MAY NOT HAVE ADEQUATE FUEL TANK PROTECTION IF THE VEHICLE HAS A MISSING OR IMPROPERLY INSTALLED CROSSMEMBER.
Manufacturer remedy
DEALERS WILL INSPECT THE VEHICLES TO MAKE SURE ALL CROSS MEMBERS ARE PROPERLY INSTALLED. IF THE CROSS MEMBER IS NOT INSTALLED CORRECTLY OR IS MISSING, THE DEALER WILL REPAIR OR INSTALL THE CROSS MEMBER.
SCHOOL, TRANSIT, OR HEAVY DUTY VEHICLES EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.
Safety risk
SEPARATION OF THE TIE ROD END COULD RESULT IN LOSS OF STEERING CONTROL, INCREASING THE RISK OF A VEHICLE CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE COMPLETE TIE ROD ASSEMBLY.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A T444E DIESEL ENGINE. THE HIGH PRESSURE OILLINE FOR THE FUEL INJECTION SYSTEM THAT GOES FROM THE HIGH PRESSURE OIL PUMP TO THE RIGHT CYLINDER HEAD CAN CHAFE AGAINST THE CHARGE AIR COOLER CROSSOVER PIPE.
Safety risk
IF THIS CONDITION OCCURS, THE HOSE WILL FAIL, RESULTING IN A SUDDEN LOSS OF OIL, CAUSING THE ENGINE TO HAVE A SUDDEN LOSS OF POWER.
Manufacturer remedy
DEALERS WILL INSPECT THE HOSES AND IF THE HOSE IS NOT DAMAGED A CONVOLUTED HOSE WILL BE PLACED OVER THE CURRENT HOSE. IF THE HOSE IS DAMAGED, IT WILL BE REPLACED ALONG WITH THE CONVOLUTED HOSE.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH T444E DIESEL ENGINES. A FUEL LEAK CAN OCCUR BECAUSE OF OVERCRIMPING OF THE HOSE END FITTINGS ON THE HOSE FROM THE REGULATOR TO THE LEFT HEAD AND THE HOSE FROM THE FUEL TRANSFER PUMP TO THE REGULATOR.
Safety risk
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A FIRE.
Manufacturer remedy
DEALERS WILL INSPECT THE OIL HOSE AND PLACE AN ADDITIONAL CONVOLUTED LOOM AROUND THE EXISTING OIL HOSE, OR REPLACE THE HOSE ASSEMBLY.
Service brakes, hydraulic: foundation components: drum: drum
Manufacturer
INTERNATIONAL TRUCK AND ENGINE
Vehicles affected
1,809
Reported to NHTSA
1998-09-17
Owners notified
1998-10-09
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A 1710 DRIVE LINE AND A 12 X 4 HYDRAULIC PARKING BRAKE. IF THE BRAKE DRUM OR TRANSMISSION YOKE ARE NOT FULLY SEATED WHEN THE EIGHT BOLTS ARE INSTALLED CONNECTING THE 3-PIECE JOINT, THE BOLTS CAN LOOSEN.
Safety risk
BOLTS WILL EVENTUALLY WORK OUT OR SHEAR RESULTING IN DRUM AND DRIVE SHAFT SEPARATION.
Manufacturer remedy
DEALERS WILL INSPECT THE TORQUE OF THESE BOLTS AND RE-TORQUE TO SPECIFICATION.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Service brakes, hydraulic: foundation components
1
—
Service brakes, hydraulic: power assist
1
—
Steering: hydraulic power assist system
1
—
The 1997 model has about 1.5 times as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.