Steering: hydraulic power assist: hose, piping, and connections
Manufacturer
PREVOST CARS, INC.
Vehicles affected
943
Reported to NHTSA
2005-03-23
Owners notified
2005-03-30
Defect description
ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE POWER STEERING HOSE CAN RUB IN THE ENGINE COMPARTMENT AND IN THE SPARE TIRE COMPARTMENT WHICH WILL CAUSE A POWER STEERING HOSE BREAK DOWN.
Safety risk
LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.
Manufacturer remedy
DEALERS WILL INSPECT THE HOSES AND REPLACE THEM IF THERE IS EVIDENCE OF WEAR FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2005. OWNERS MAY CONTACT PREVOST AT 418-831-5432.
ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE STEERING COLUMNS MAY BE MISSING THE LOWER BOLT AND NUT. A REPLACEMENT BOLT AND NUT WAS INSTALLED TO CORRECT THIS SITUATION ON THE PRODUCTION LINE. IF A REPLACEMENT BOLT HAS BEEN USED AND NOT TIGHTENED PROPERLY, THE COLUMN MAY COME OUT OF THE INPUT SHAFT WHEN THE STEERING COLUMN ADJUSTMENT MECHANISM IS USED.
Safety risk
IN SUCH A CASE, A LOSS OF STEERING WOULD OCCUR.
Manufacturer remedy
DEALERS WILL VERIFY THE SIZE OF THE BOLT AND NUT AND REPLACE THEM IF NEEDED. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.
ON CERTAIN COACHES AND BUS SHELLS EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Safety risk
IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN DECEMBER 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.