Spartan Motors USA (Spartan) is recalling certain model year 1997-2005 MM and K2 motorhome chassis manufactured January 20, 2003, to May 16, 2005. The affected vehicles have a steering gear mounting bracket that may crack, causing a loss of steering ability.
Safety risk
A loss of steering increases the risk of a crash.
Manufacturer remedy
Spartan will notify owners, and dealers will replace the steering gear mounting brackets, free of charge. An interim notice was mailed to owners on December 4, 2015. Owners may contact Spartan customer service at 1-800-543-4277. Spartan's number for this recall is 15022.
Spartan Motors USA (Spartan) is recalling certain model year 2004-2008 K2, K3 and MM motorhomes manufactured March 17, 2003, to March 15, 2007. In the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.
Safety risk
If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.
Manufacturer remedy
Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. Interim notices were mailed to owners on October 29, 2015. The recall began on October 29, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15014.
ON CERTAIN MOTOR HOMES, THE I-SHAFT IS THE MECHANICAL LINKAGE BETWEEN THE STEERING WHEEL AND THE STEERING GEAR. AT THE NON-WELDED SIDE OF THE I-SHAFT THERE IS A UNIVERSAL JOINT. IT IS POSSIBLE THAT THE FORK SHAFT CONNECTION COULD BE LOST.
Safety risk
DRIVERS WILL LOSE STEERABILITY OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Manufacturer remedy
DEALERS WILL INSPECT AND REPAIR THE I-SHAFT. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT SPARTAN AT 517-543-6400.
ON CERTAIN MOTOR HOMES EQUIPPED WITH NGI AIR PRESSURE GAUGES LOCATED ON THE DASH PANEL IS GIVING A FALSE READING.
Safety risk
THIS MAY CAUSE THE PARK BRAKE TO ENGAGE WITHOUT WARNING, THUS THROWING THE PASSENGER FORWARD, CREATING THE POTENTIAL FOR INJURY TO OCCUPANTS.
Manufacturer remedy
DEALERS WILL USE A JUMPER HARNESS CONTAINING A 33 OHM RESISTOR WHICH WILL SHIFT THE RESISTANCE CURVE OF THE AIR PRESSURE SENDER TO MATCH THE ALARM POINT OF THE CURRENT GAUGE. THE RECALL BEGAN ON JUNE 3, 2005. OWNERS MAY CONTACT SPARTAN AT 517-543-6400.
ON CERTAIN MOTORHOMES EQUIPPED WITH TUTHILL INDEPENDENT FRONT SUSPENSIONS, THE DEFECT IS INSUFFICIENT TIGHTENING TORQUE OF THE STEERING KNUCKLE CARRIER BOLT THAT MAY RESULT IN SEPARATION OF THE STEERING KNUCKLE FROM ONE OF THE CONTROL ARMS.
Safety risk
SHOULD THE STEERING KNUCKLE CARRIER SEPARATE FROM THE CONTROL ARM, THE OPERATOR COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
Manufacturer remedy
TUTHILL WILL NOTIFY ITS CUSTOMERS AND PROVIDE A RETROFIT KIT P/N K704627 FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TUTHILL TRANSPORT TECHNOLOGIES AT 800-225-7824 (EXT. #390) OR SPARTAN AT 517-543-6400.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.