Spartan Motors (Spartan) is recalling certain model year 2007-2015 Spartan K3 and MM motorhome chassis manufactured September 21, 2006, to March 23, 2015. In the affected vehicles, the flexible exhaust tube may tear allowing hot exhaust to blow against other components or materials.
Safety risk
If hot exhaust gas contacts other components or materials, it can increase the risk of a fire.
Manufacturer remedy
Spartan will notify the motorhome manufacturers that purchased the affected chassis, and Spartan dealers will inspect the alignment of the tubes, correcting them and replacing any that are torn. These repairs will be performed free of charge. The recall began on June 23, 2016. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 16014. Note: This recall supersedes 15V-554.
Spartan Motors USA (Spartan) is recalling certain model year 2004-2008 K2, K3 and MM motorhomes manufactured March 17, 2003, to March 15, 2007. In the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.
Safety risk
If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.
Manufacturer remedy
Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. Interim notices were mailed to owners on October 29, 2015. The recall began on October 29, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15014.
Spartan Motors Chassis (Spartan) is recalling certain model year 2006-2011 K2, and K3 and 2006-2010 MM motorhome chassis manufactured July 20, 2005, through December 17, 2010. The steering gear mounting brackets may crack and detach resulting in a loss of steering.
Safety risk
A loss of steering control may increase the risk of a crash.
Manufacturer remedy
Spartan will notify owners. Starting in mid-June 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. Until the remedy is available, owners may have their vehicle inspected at any Spartan service center. All repairs will be performed free of charge. Notices were mailed to owners on June 24, 2013. Owners can contact Spartan at 1-855-589-9836.
Electrical system: wiring: fuses and circuit breakers
Manufacturer
SPARTAN CHASSIS, INC.
Vehicles affected
54
Reported to NHTSA
2006-03-31
Owners notified
2006-04-10
Defect description
ON CERTAIN MOTOR HOMES, THE BUSSMAN BOX WAS INCORRECTLY SOLDERED AND COULD FAIL.
Safety risk
ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUTDOWN AND/OR NOT BE CAPABLE OF POWERING UP. ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS MAY OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION STARTING AND ENGINE COOLING SYSTEMS, IN THE OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, ANTILOCK BRAKE SYSTEM (ABS), AUXILIARY BRAKE SYSTEM, HEATER ELEMENTS IN THE AIR DRYER, AND/OR THE HEATER ELEMENT IN THE WATER IN-FUEL SEPARATOR, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE DEFECTIVE COMPONENTS. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.