CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Safety risk
INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Manufacturer remedy
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.
CERTAIN MODEL YEAR 2000-2003, 2005 AND 2006 THOMAS BUILT MINOTOUR SCHOOL BUSES BUILT ON FORD AND GM CHASSIS FROM APRIL 17, 2000, THROUGH AUGUST 29, 2008. THESE BUSES WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Safety risk
INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Manufacturer remedy
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL BEGAN ON MAY 24, 2011.
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.
Safety risk
IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.
Manufacturer remedy
DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.