Daimler Trucks North America LLC (DTNA) is recalling certain model year 1998-2002 Thomas Built Buses Saf-T-Liner Conventional, 2000-2002 Saf-T-Liner ER, 2000-2002 Saf-T-Liner MVP-EF, 2000-2001 CL-960, 1998-1999 Vista, 2000-2002 Saf-T-Liner MVP-ER, and 2000-2002 TL-960 transit buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Safety risk
If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Manufacturer remedy
DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was sent to owners on July 28, 2016. A second notice was mailed to owners on December 9, 2016 Parts are available. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-713.
Daimler Trucks North America LLC (DTNA) is recalling certain model year 1998-2002 Thomas Built Buses Saf-T-Liner Conventional, 2000-2002 Saf-T-Liner ER, 2000-2017 Saf-T-Liner MVP-EF, 1998-1999 Vista, 2003 Saf-T-Liner FS65, 2013-2017 Saf-T-liner C2, 2000-2002 Saf-T-Liner MVP-ER, 2013-2017 Saf-T-Liner HDX. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Safety risk
If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Manufacturer remedy
DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was sent to owners on July 28, 2016. A second notice was mailed to owners on December 16, 2016. Parts are available. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-713.
ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH REYCO REAR AXLE AIR SUSPENSIONS, DEFLATED SUSPENSION AIR BAGS COULD CREATE EXCESSIVE DRIVELINE ANGLES CAUSING U-JOINT DAMAGE.
Safety risk
THE DRIVE SHAFT COULD FALL OFF OF THE BUS. FOLLOWING VEHICLES COULD THEN RUN OVER THIS OBSTACLE, INCREASING THE RISK OF DAMAGE TO THE FOLLOWING VEHICLE.
Manufacturer remedy
DEALERS WILL INSTALL AXLE STOPS TO LIMIT REAR SUSPENSION TRAVEL AND FASTENER TORQUE WILL BE CHECKED ON THE SUSPENSION HEIGHT CONTROL ROD. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES BUILT WITH COMPOSITE FRONT ROOF CAPS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." THE ROOF CAP DOES NOT MEET THE REQUIREMENTS DUE TO THE OMISSION OF THE ADHESIVE THAT JOINS THE ROOF TO THE BUS BODY.
Safety risk
IN THE EVENT OF A CRASH, THE ROOF OF THE VEHICLE MAY CRUSH, NOT PROPERLY PROTECTING THE VEHICLE OCCUPANTS.
Manufacturer remedy
DEALERS WILL RE-BOND THE ROOF CAP TO THE ROOF SHEET METAL. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.