Engine and engine cooling: cooling system: hoses/lines/piping/fittings
Manufacturer
Daimler Trucks North America, LLC
Vehicles affected
2,843
Reported to NHTSA
2026-02-13
Owners notified
2026-04-10
Defect description
Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2026 Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Safety risk
Contact with hot heating coolant may burn occupants, increasing the risk of injury.
Manufacturer remedy
Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.
Engine and engine cooling: cooling system: hoses/lines/piping/fittings
Manufacturer
Daimler Trucks North America, LLC
Vehicles affected
52
Reported to NHTSA
2026-02-13
Owners notified
2026-04-10
Defect description
Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2025 Saf-T-Liner EFX and 2023-2026 Saf-T-Liner HDX vehicles. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
Safety risk
Contact with hot heating coolant may burn occupants, increasing the risk of injury.
Manufacturer remedy
Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Safety risk
A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Manufacturer remedy
Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.
Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2023 Thomas Built Saf-T-Liner HDX school buses. The rear exterior side-body panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Safety risk
A school bus panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Manufacturer remedy
Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall FL953.
Engine and engine cooling: engine: engine control module (ECU/ECM)
Manufacturer
Daimler Trucks North America, LLC
Vehicles affected
71
Reported to NHTSA
2022-07-29
Owners notified
2022-09-27
Defect description
Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Thomas Built Saf-T-Liner HDX and Saf-T-Liner C2 school buses. The engine control module (ECM) may experience an internal short-circuit, which can result in an unexpected engine shut down.
Safety risk
Unexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Manufacturer remedy
Cummins will replace the ECM, free of charge. Owner notification letters are expected to be mailed September 26, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-949.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.
Safety risk
Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.
Manufacturer remedy
Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX school buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.
Safety risk
An electrical short circuit can increase the risk of a fire.
Manufacturer remedy
Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL928.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2019-2023 Thomas Built Bus HDX commercial buses. The positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit.
Safety risk
An electrical short circuit can increase the risk of a fire.
Manufacturer remedy
Dealers will inspect and repair the cable routing, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL929.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.