Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.
Safety risk
If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.
Manufacturer remedy
Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.
Tiffin Motorhomes is recalling certain model year 2010-2013 Allegro Bus motorcoaches, manufactured from March 2010, through September 2012 and equipped with a Cummins EPA 2010 ISL engine. Insufficient shielding between the exhaust pipe and floor may cause possible overheating of the floor above the engine compartment.
Safety risk
If the exhaust pipe in the engine compartment were to fail, the escaping exhaust gases could make the floor area above the engine extremely hot, increasing the risk of personal injury or possibly resulting in a fire.
Manufacturer remedy
Tiffin Motorhomes will notify owners, and dealers will install a heat shield, free of charge. The safety recall began on November 14, 2012. Owners may contact Tiffin at 1-256-356-8661.
TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO BUS AND PHAETON RECREATIONAL VEHICLES BUILT ON THE POWERGLIDE CHASSIS EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Safety risk
IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
Manufacturer remedy
TIFFIN MOTORHOMES IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN MOTORHOMES AT 1-256-356-8661.
TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
Safety risk
A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Manufacturer remedy
TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Structure
1
48,000 mi
The 2010 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.