SOME OF THE VEHICLES MAY HAVE MANGANESE BRONZE SPRING CLIP PLATES USED AS A SUBSTITUTE FOR MALLEABLE IRON. THE SUBSTITUTE CLIPS, WHICH ARE USED TO ATTACH THE SUSPENSION SPRING TO THE REAR AXLE, MAY CRACK ALLOWING THE ASSEMBLY TO LOOSEN. THIS CAN CAUSE REAR AXLE DISPLACEMENT.
Manufacturer remedy
THE DEALER WILL REPLACE THE MANGANESE BRONZE CLIPS WITH MALLEABLE IRON CLIP PLATES AT NO COST TO OWNER.
LOSS OF LIGHTS AND ENGINE SHUTDOWN MAY OCCUR AS A RESULT OF ELECTRICAL SYSTEM FAILURE DUE TO IMPROPER CIRCUIT CRIMPING AND POTENTIAL HEATER MOTOR CIRCUIT OVERLOADING. ALSO, THE FUEL SOLENOID MAY BE IMPROPERLY FUSED AND THE HEADLIGHT HARNESS IMPROPERLY ROUTED.
Manufacturer remedy
THE DEALER WILL MAKE THE NECESSARY CORRECTIONS, FREE OF CHARGE TO THE OWNER.
Service brakes, air: supply: hoses, lines/piping, and fittings
Manufacturer
WHITE MOTOR CORPORATION
Vehicles affected
140
Reported to NHTSA
1978-07-06
Owners notified
1978-09-11
Defect description
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", IN THAT SOME DUAL COMPARTMENT AIR RESERVOIRS WERE INSTALLED WITHOUT A DRAIN VALVE IN BOTH COMPARTMENTS. THE OMISSION OF THE DRAIN VALVE COULD CAUSE: 1) THE TANK TO FILL UP WITH WATER DUE TO CONDENSATION, 2) REDUCED AIR VOLUME, 3) CONTAMINATION OF THE AIR SYSTEM WITH WATER, CAUSING MALFUNCTION OF THE RELEASE VALVES, CHECK VALVES, ETC., AND INCREASING THE POSSIBILITY OF AIR SYSTEM COMPONENT FREEZE-UP IN COLD CLIMATES. THESE CONDITIONS COULD RESULT IN MOMENTARY LOSS OF BRAKING ACTION.
Manufacturer remedy
DEALER WILL INSPECT AND, IF NECESSARY, INSTALL A DRAIN VALVE AT NO COST TO OWNER.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.