WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Safety risk
THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Manufacturer remedy
WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO IS RECALLING MY 1999-2002 ULTIMATE ADVANTAGE, ULTIMATE FREEDOM, MY 1999-2001 CHIEFTAIN, MY 2000-2001 BRAVE, MY 2001 JOURNEY MY 2000 MINNIE WINNIE, MY 2000-2002 ITASCA HORIZON, MY 1999 SUNCRUISER, MY 2001 SUNFLYER, AND MY 2000 SUNRISE MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Safety risk
EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Manufacturer remedy
WINNEBAGO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Safety risk
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Manufacturer remedy
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR WINNEBAGO AT 641-585-3535.
Service brakes, hydraulic: brake fluid low warning: lamp
Manufacturer
WINNEBAGO INDUSTRIES, INC.
Vehicles affected
8,532
Reported to NHTSA
2003-02-21
Owners notified
2003-04-25
Defect description
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.
Safety risk
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.
Manufacturer remedy
DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.
Fuel system, other: storage: tank assembly: mounting
Manufacturer
WINNEBAGO INDUSTRIES, INC.
Vehicles affected
101
Reported to NHTSA
2001-07-03
Owners notified
2001-07-19
Defect description
VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON A FORD CHASSIS. THESE VEHICLES MAY HAVE THE INCORRECT LIQUID PROPANE (LP) GAS TANK BRACKET. DEPENDING ON HOW THE TANK WAS INSTALLED, THERE MAY NOT BE ADEQUATE CLEARANCE BETWEEN THE TANK AND A BOLT HEAD ON THE SUSPENSION. WITHOUT CLEARANCE, THE TANK COULD BE DAMAGED.
Safety risk
OVER TIME, COULD DEVELOP A LEAK WHICH HAS THE POTENTIAL TO IGNITE, RESULTING IN BODILY INJURY AND/OR PROPERTY DAMAGE.
Manufacturer remedy
DEALERS WILL REPOSITION THE LP GAS TANK. OWNER NOTIFICATION BEGAN JULY 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Safety risk
SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Manufacturer remedy
DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. OWNER NOTIFICATION BEGAN MAY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 1-219-266-8330 OR WINNEBAGO AT 1-641-585-6939.
Fuel system, other: delivery: hoses, lines/piping, and fittings
Manufacturer
WINNEBAGO INDUSTRIES, INC.
Vehicles affected
1,437
Reported to NHTSA
2001-03-26
Owners notified
2001-04-12
Defect description
VEHICLE DESCRIPTION: MOTOR HOMES. THE COPPER LINE SUPPLYING LIQUID PROPANE GAS (LPG) TO THE FURNACE MAY HAVE BEEN IMPROPERLY CLAMPED, WHICH COULD CAUSE THE LINE TO COME IN CONTACT WITH A METAL FLANGE.
Safety risk
IF THIS HAPPENS, THE COPPER LINE COULD BE DAMAGED AND COULD DEVELOP A LEAK WHICH HAS THE POTENTIAL TO IGNITE.
Manufacturer remedy
DEALERS WILL RE-ROUTE THE LPG LINE. OWNER NOTIFICATION BEGAN APRIL 12, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Electrical system: ignition: switch
1
24,000 mi
Electronic stability control: automatic (ASC)
1
8,895 mi
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
1
—
Service brakes, hydraulic: antilock/traction control/electronic limited slip
1
26,200 mi
Service brakes, hydraulic: foundation components: disc: rotor
1
26,200 mi
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
1
—
Structure: frame and members
1
—
The 2000 model has about half as many complaints as this one. The 2002 model has about a third as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.