Known Recalls

Model year record

1995 Chevrolet Tahoe

6 recall campaigns on file for this model year. 296 owner complaints on file.

Chevrolet Tahoe, 1995–1999 generation
Pictured: the 1995–1999 generation. IFCAR, Public domain · Wikimedia Commons

Recalls

Recall campaignNHTSA 03V159000

Visibility: windshield wiper/washer

Component
Visibility: windshield wiper/washer
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
1,755,876
Reported to NHTSA
2003-04-28
Owners notified
2003-06-19

Defect description

ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.

Safety risk

IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.

Recall campaignNHTSA 98V150001

Visibility: windshield wiper/washer

Component
Visibility: windshield wiper/washer
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
1,557,585
Reported to NHTSA
1998-07-01
Owners notified
1998-12-15

Defect description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.

Safety risk

THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.

Recall campaignNHTSA 96V057000

Vehicle speed control

Component
Vehicle speed control
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
379,004
Reported to NHTSA
1996-04-04
Owners notified
1996-04-11

Defect description

THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."

Safety risk

CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.

Recall campaignNHTSA 95V139000

Power train: automatic transmission

Component
Power train: automatic transmission
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
36,641
Reported to NHTSA
1995-07-26
Owners notified
1995-08-10

Defect description

THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.

Safety risk

THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.

Manufacturer remedy

DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.

Recall campaignNHTSA 95V140000

Air bags

Component
Air bags
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
3,651
Reported to NHTSA
1995-07-25
Owners notified
1995-08-03

Defect description

THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."

Safety risk

CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.

Manufacturer remedy

THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.

Recall campaignNHTSA 95V081000

Seat belts: rear/other

Component
Seat belts: rear/other
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
8,323
Reported to NHTSA
1995-04-24
Owners notified
1995-05-03

Defect description

VEHICLES FAIL TO CONFORM TO FMVSS NO. 210, "SEAT BELT ANCHORAGES." THE CENTER REAR SEAT LAP BELT WAS IMPROPERLY ROUTED.

Safety risk

CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANT OF THIS SEAT WILL NOT BE PROPERLY RESTRAINED IN THE EVENT OF A VEHICLE CRASH.

Manufacturer remedy

INSTRUCTIONS FOR REROUTING THE CENTER REAR SEAT LAP BELT WILL BE SENT TO THE VEHICLE OWNERS. IF THE OWNER PREFERS, THEY CAN TAKE THEIR VEHICLE TO THEIR DEALER AND HAVE IT REROUTED FREE OF CHARGE BY THE DEALER.

Owner complaints

A complaint is one person's report to a federal agency. It is not a finding.

ComponentComplaintsMedian mileage
Seats56101,389 mi
Service brakes, hydraulic: antilock/traction control/electronic limited slip36107,000 mi
Electrical system: 12V/24V/48V battery22—
Seats: front assembly: recliner14—
Air bags: frontal10—
Air bags9—
Visibility: windshield wiper/washer9—
Seats: front assembly: power adjust7—
Seat belts: front: retractor6—
Tires: tread/belt6—
Unknown or other697,000 mi
Visibility: windshield wiper/washer: motor6—
Power train: automatic transmission521,838 mi
Electrical system4120,000 mi
Electrical system: 12V/24V/48V battery: cables4—
Service brakes, hydraulic: foundation components4—
Service brakes, hydraulic: foundation components: disc: rotor484,775 mi
Structure: body4120,000 mi
Suspension: front4196,000 mi
Tires4—
Vehicle speed control4—
Fuel system, gasoline: fuel injection system3—
Power train: axle assembly3—
Power train: axle assembly: axle shaft: seal3—
Structure: body: door3—
Electrical system: horn2—
Latches/locks/linkages: hood: latch2—
Power train: driveline: differential unit2—
Seat belts2—
Seat belts: rear/other2—
Service brakes, hydraulic: foundation components: disc2—
Service brakes, hydraulic: power assist: vacuum2—
Steering2—
Steering: steering wheel/handle bar2—
Structure: frame and members2—
Suspension: rear2—
Visibility: windshield2—
Air bags: frontal: sensor/control module1—
Electrical system: ignition1—
Electrical system: wiring1—
Electrical system: wiring: front underhood1115,000 mi
Electrical system: wiring: fuses and circuit breakers1—
Electrical system: wiring: interior/under dash1—
Engine and engine cooling: exhaust system1—
Engine and engine cooling: exhaust system: emission control1—
Engine and engine cooling: exhaust system: emission control: gas recirculation valve (EGR valve)1—
Equipment: appliance: air conditioner1—
Equipment: mechanical: carrier/rack1—
Exterior lighting1120,000 mi
Exterior lighting: back up lights1—
Fuel system, gasoline1125,000 mi
Fuel system, gasoline: delivery: fuel pump1—
Fuel/propulsion system1264,349 mi
Interior lighting1—
Latches/locks/linkages: doors: latch1—
Power train: clutch assembly1—
Power train: driveline1—
Power train: transfer case (4-wheel drive)1—
Seat belts: front: anchorage1—
Seat belts: front: buckle assembly1—
Seat belts: front: webbing1—
Seats: front assembly: head restraint1—
Service brakes195,000 mi
Service brakes, hydraulic1—
Service brakes, hydraulic: foundation components: disc: caliper1—
Service brakes, hydraulic: foundation components: disc: pads1—
Service brakes, hydraulic: foundation components: drum1—
Service brakes, hydraulic: foundation components: master cylinder1—
Service brakes, hydraulic: pedals and linkages1—
Steering: hydraulic power assist system1120,072 mi
Structure: body: hood1—
Structure: body: tailgate: hinge and attachments1—
Vehicle speed control: cruise control1—

The 1994 model has 15 times as many complaints as this one. The 1996 model has about half as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.

Other Chevrolet Tahoe model years

2026202520242023202220212020201920182017201620152014201320122011201020092008200720062005200420032002200120001999199819971996199519941993199219911988

All Chevrolet Tahoe recalls by year

Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.