Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe
Manufacturer
General Motors LLC
Vehicles affected
1,003,556
Reported to NHTSA
2015-10-26
Owners notified
2016-02-19
Defect description
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Safety risk
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Manufacturer remedy
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Safety risk
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Manufacturer remedy
DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Safety risk
CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Manufacturer remedy
DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Engine
32
138,000 mi
Electrical system
14
120,000 mi
Engine and engine cooling
8
95,421 mi
Engine and engine cooling: engine
5
1,870 mi
Exterior lighting
4
120,000 mi
Tires
4
700 mi
Electrical system: ignition
3
5,000 mi
Fuel system, gasoline
3
60,000 mi
Service brakes
3
90,000 mi
Structure
3
—
Suspension
3
92,000 mi
Electrical system: wiring
2
60,000 mi
Engine and engine cooling: exhaust system
2
84,917 mi
Equipment
2
10,000 mi
Exterior lighting: headlights
2
3,400 mi
Power train
2
59,000 mi
Power train: automatic transmission
2
117,000 mi
Seats
2
44,000 mi
Seats: front assembly: seat heater/cooler
2
10,000 mi
Service brakes, hydraulic
2
100,000 mi
Service brakes, hydraulic: antilock/traction control/electronic limited slip
2
8,500 mi
Service brakes, hydraulic: foundation components: disc: rotor
2
500 mi
Structure: body
2
122,972 mi
Structure: body: door
2
41 mi
Structure: body: door: hinge and attachments
2
—
Unknown or other
2
233,000 mi
Vehicle speed control
2
9,500 mi
Vehicle speed control: accelerator pedal
2
9,500 mi
Visibility: power window devices and controls
2
40,000 mi
Wheels
2
700 mi
Air bags
1
78,000 mi
Air bags: frontal
1
139,088 mi
Electrical system: instrument cluster/panel
1
100,000 mi
Electrical system: horn
1
12,000 mi
Engine and engine cooling: cooling system
1
—
Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe
1
33,345 mi
Equipment: electrical: radio/tape deck/CD etc.
1
700 mi
Exterior lighting: brake lights
1
68,231 mi
Exterior lighting: turn signal: switch
1
700 mi
Fuel system, other: storage: tank assembly: pressure relief devices
1
—
Fuel/propulsion system
1
—
Latches/locks/linkages: doors: latch
1
87,000 mi
Seat belts
1
139,088 mi
Seats: front assembly: power adjust
1
—
Steering
1
180,000 mi
Steering: hydraulic power assist system
1
87,000 mi
Visibility: defroster/defogger/hvac system
1
78,000 mi
Visibility: windshield wiper/washer
1
700 mi
The 2002 model has about a third as many complaints as this one. The 2004 model has about a fifth as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.