Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2019-2022 Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, Minotour DRW, 2020-2022 Saf-T-Liner C2 Jouley, and Minotour SRW school buses. The Emergency Exit Label lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window Retention and Release."
Safety risk
Emergency exit labels that are difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Manufacturer remedy
Dealers will correct the lettering, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL918.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Safety risk
A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Manufacturer remedy
Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.
Safety risk
Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.
Manufacturer remedy
Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Thomas Built Buses Saf-T-Liner EFX School Buses. The passenger seat mounting bolts may break due to improperly placed mounting that allows contact with the chassis cross member bolts. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 210, "Seat Belt Assembly Anchorage" and 222, "School Bus Passenger Seating and Crash Protection."
Safety risk
A seat with broken mounting bolts may not properly restrain an occupant in a crash, increasing their risk of injury.
Manufacturer remedy
Dealers will add a spacer to provide proper clearance between the passenger seat mounting and chassis cross member bolts, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-921.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2022 Thomas Built EFX and HDX school buses. The nut for the power cable stud on the alternator may not have been tightened properly, which can cause a loose cable connection.
Safety risk
A loose power cable connection may cause electrical arcing, which can increase the risk of a fire.
Manufacturer remedy
Dealers will inspect the alternator power cable connection and tighten it if necessary, free of charge. Owner notification letters were mailed on December 17, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL904.
Daimler Trucks North America LLC (DTNA) is recalling certain 2019-2020 Thomas Built Saf-T-Liner HDX, EFX, and C2 school buses equipped with air disc brakes. The brake caliper mounting bolts may have been insufficiently tightened.
Safety risk
Loose brake caliper mounting bolts can reduce brake effectiveness, increasing the risk of a crash.
Manufacturer remedy
DTNA will notify owners, and dealers will inspect and repair the vehicles, free of charge. The recall began May 2, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-845.
Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2020 Thomas Built Saf-T-Liner EFX, Minotour, Saf-T-Liner C2, and Saf-T-Liner HDX school buses equipped with SynTec S3B or S3C seats. The seats may have been manufactured with styrene blocks that may not provide sufficient impact absorption in certain specific areas around the steel seat frame of the back support. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection."
Safety risk
The lack of impact absorption increases the risk of injury in the event of a crash.
Manufacturer remedy
DTNA will notify owners, and dealers will install additional impact material between the re-bond back and the vinyl back cover to increase the amount of absorption, free of charge. DTNA issued owners an interim notification on November 29, 2019. The recall began June 22, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-832.
Daimler Trucks North America LLC (DTNA) is recalling certain 2019-2020 Thomas Built Minotour, Saf-T Liner C2, Saf-T Liner EFX, and Saf-T Liner HDX school buses equipped with Safe Fleet Prolo Roof Escape hatches. Due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use.
Safety risk
If the roof hatch external handle breaks, in the event of an emergency, the hatch cannot be easily opened from outside the vehicle, increasing the risk of injury.
Manufacturer remedy
DTNA will notify owners, and dealers will install a new handle, free of charge. Owners were issued an interim notification on September 13, 2019. The recall began November 15, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-819.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.