Known Recalls

Model year record

2000 Buick Regal

8 recall campaigns on file for this model year. 245 owner complaints on file.

Recalls

Recall campaignNHTSA 15V701000

Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe

Component
Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe
Manufacturer
General Motors LLC
Vehicles affected
1,003,556
Reported to NHTSA
2015-10-26
Owners notified
2016-02-19

Defect description

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Safety risk

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Manufacturer remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Recall campaignNHTSA 09V116000

Engine and engine cooling

Component
Engine and engine cooling
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
1,497,516
Reported to NHTSA
2009-04-08
Owners notified
2009-04-09

Defect description

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Safety risk

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Recall campaignNHTSA 08V118000

Engine and engine cooling

Component
Engine and engine cooling
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
207,542
Reported to NHTSA
2008-03-12
Owners notified
2008-04-28

Defect description

GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.

Safety risk

CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.

Manufacturer remedy

DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Recall campaignNHTSA 01V109000

Seat belts

Component
Seat belts
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
116,007
Reported to NHTSA
2001-04-06
Owners notified
2001-05-04

Defect description

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Safety risk

THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.

Manufacturer remedy

GM WILL MAIL A NEW BILINGUAL AIR BAG LABEL WITH INSTALLATION INSTRUCTIONS. HOWEVER, THE CUSTOMER MAY BRING THE LABEL TO THEIR DEALER FOR INSTALLATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT OLDSMOBILE AT 1-800-442-6537 OR BUICK AT 1-800-521-7300.

Recall campaignNHTSA 00V371000

Air bags: side/window

Component
Air bags: side/window
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
12
Reported to NHTSA
2000-11-13
Owners notified
2000-11-16

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.

Safety risk

IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.

Manufacturer remedy

DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.

Recall campaignNHTSA 00V228003

Seat belts

Component
Seat belts
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
156,305
Reported to NHTSA
2000-08-07
Owners notified
2000-08-24

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety risk

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Manufacturer remedy

DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Recall campaignNHTSA 00V160000

Fuel system, gasoline: storage: tank assembly: filler pipe and cap

Component
Fuel system, gasoline: storage: tank assembly: filler pipe and cap
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
248
Reported to NHTSA
2000-06-16
Owners notified
2000-06-21

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CLAMP THAT SECURES THE FLEXIBLE FUEL FILL HOSE TO THE METAL FILL TUBE MAY BE LOOSE AND COULD SEPARATE.

Safety risk

THIS COULD CAUSE FUEL LEAKAGE EXCEEDING THE PERMISSIBLE AMOUNT.

Manufacturer remedy

DEALERS WILL INSPECT THE FUEL HOSE FILL NECK CLAMP AND, IF NECESSARY, REPOSITION AND TIGHTEN THE CLAMP.

Recall campaignNHTSA 00V143000

Service brakes, hydraulic: foundation components: drum

Component
Service brakes, hydraulic: foundation components: drum
Manufacturer
GENERAL MOTORS CORP.
Vehicles affected
18,754
Reported to NHTSA
2000-05-17
Owners notified
2000-06-23

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH REAR DRUM BRAKES. THE BOLT HEAD(S) ON THE REAR SPINDLE ROD CAN SEPARATE.

Safety risk

THE REAR WHEEL CAN SHIFT, CAUSING REAR STEERING OF THE VEHICLE. THE DRIVER COULD LOSE CONTROL AND A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL REPLACE THE REAR SPINDLE BOLTS.

Owner complaints

A complaint is one person's report to a federal agency. It is not a finding.

ComponentComplaintsMedian mileage
Electrical system33106,000 mi
Engine28140,000 mi
Engine and engine cooling25100,000 mi
Steering1487,500 mi
Air bags1150,000 mi
Service brakes, hydraulic: antilock/traction control/electronic limited slip937,000 mi
Air bags: frontal850,000 mi
Steering: rack and pinion852,718 mi
Engine and engine cooling: engine797,000 mi
Suspension637,000 mi
Fuel/propulsion system5137,000 mi
Steering: linkages: tie rod assembly518,524 mi
Structure: body5126,000 mi
Unknown or other589,000 mi
Vehicle speed control599,139 mi
Visibility: power window devices and controls550,000 mi
Electrical system: ignition4100 mi
Power train: automatic transmission4—
Tires: tread/belt420,000 mi
Wheels3—
Electrical system: instrument cluster/panel2135,000 mi
Electrical system: ignition: switch271,450 mi
Equipment: appliance: air conditioner2—
Exterior lighting220,000 mi
Exterior lighting: headlights: high/low beam dimmer switch281,000 mi
Steering: steering wheel/handle bar2—
Suspension: front2150,000 mi
Tires2—
Air bags: frontal: sensor/control module122,000 mi
Air bags: side/window1—
Electrical system: 12V/24V/48V battery: cables1—
Electrical system: ignition: module1—
Electrical system: wiring120,000 mi
Electronic stability control (ESC)1150,000 mi
Engine and engine cooling: cooling system1190,387 mi
Engine and engine cooling: exhaust system: emission control1137,000 mi
Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe170,280 mi
Equipment: recreational vehicle/trailer: LPG systems: tank valve/gauge1190,387 mi
Exterior lighting: fog lights1—
Exterior lighting: headlights111,190 mi
Exterior lighting: turn signal: flasher unit1—
Firerelated1187,000 mi
Fuel system, gasoline1—
Fuel system, gasoline: fuel injection system1117,000 mi
Parking brake150,000 mi
Seat belts: rear/other1—
Service brakes, hydraulic135,000 mi
Service brakes, hydraulic: antilock/traction control/electronic limited slip: control unit/module183,000 mi
Service brakes, hydraulic: foundation components: disc: rotor1—
Service brakes, hydraulic: foundation components: master cylinder180,000 mi
Steering: gear box (other than rack and pinion)187,500 mi
Steering: hydraulic power assist system135,000 mi
Steering: hydraulic power assist: hose, piping, and connections158,000 mi
Structure171,000 mi
Structure: body: trunk lid135,000 mi
Suspension: rear172,000 mi
Tires: valve1—
Visibility1—
Visibility: rear window wiper/washer: motor1—
Visibility: rearview mirrors/devices1—
Visibility: rearview mirrors/devices: exterior1—
Visibility: windshield wiper/washer1—
Wheels: rim1130,000 mi

The 1999 model has roughly the same number of complaints as this one. The 2001 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.

Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.