Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Safety risk
An electrical arc increases the risk of a fire.
Manufacturer remedy
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2018 Reflection trailers. A wiring connector in the vehicle underbody may not be properly secured, allowing water intrusion into the wiring connector, possibly resulting in an electrical short circuit.
Safety risk
If water enters the wiring connector, it can cause a short circuit, increasing the risk of a fire.
Manufacturer remedy
Grand Design will notify owners, and dealers will inspect and secure the wiring connectors up to prevent water intrusion, free of charge. This recall began June 29, 2020. Owners may contact Grand Design's customer service at 1-574-825-9679. Grand Design's number for this recall is 910020.
Grand Design RV, LLC is recalling certain 2018-2019 Reflection fifth wheel trailers, models 28BH and 29RS. The circuit for the power converter does not have over-current protection.
Safety risk
An electrical short circuit in the unprotected circuit can increase the risk of a fire.
Manufacturer remedy
Grand Design RV will notify owners, and dealers will inspect the trailers to determine if the 50-amp mini breaker at the bus bar is installed correctly and that the circuit is wired correctly, correcting it as necessary, free of charge. The recall began November 19, 2018. Owners may contact Grand Design RV customer service at 1-574-825-9679. Grand Design RV's number for this recall is 910017.
Grand Design RV, LLC (Grand Design) is recalling certain 2017-2018 Reflection and Imagine travel trailers equipped with a Smart-Jack model power tongue jack. The laminated plastic touch pad on the jack may crack or separate allowing water to enter, potentially causing the jack to operate unintentionally.
Safety risk
If the tongue jack retracts or extends unexpectedly, there could be an increased risk of a crash or injury.
Manufacturer remedy
Grand Design will notify owners, and dealers will replace the power tongue jack, free of charge. The recall began on December 29, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 900012.
Grand Design RV, LLC (Grand Design) is recalling certain 2018 Reflection travel trailers, model 297RSTS. These vehicles may have insufficient clearance between the tire and the ram that moves the slide out room. The tire can contact the ram for the slide out room while the trailer is being towed, causing tire damage or a possible tire blowout.
Safety risk
Tire failure can increase the risk of a crash.
Manufacturer remedy
Grand Design will notify owners, and dealers will install a lift kit at each of the axle hangers, giving two additional inches of clearance. Tires that show evidence of damage will be replaced. These repairs will be performed free of charge. The recall began on December 14, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910011.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
Component
Complaints
Median mileage
Suspension
5
9,000 mi
Service brakes
3
60 mi
Structure
2
—
Equipment
1
10,000 mi
Power train
1
11,500 mi
Power train: axle hubs
1
11,500 mi
Structure: body
1
—
The 2017 model has about half as many complaints as this one. The 2019 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.