Nova Bus is recalling certain model year 2001-2004 LFS buses manufactured January 1, 2001, to December 31, 2004. The affected vehicles have certain air hoses that may have been incorrectly connected to the R14 valve, causing a delay when applying the parking brake.
Safety risk
A delay in the application of the parking brake may result in the bus rolling forward or rearward a few feet, increasing the risk of a crash.
Manufacturer remedy
Nova Bus is confirming that all buses were inspected and repaired. Nova Bus will notify the owner of any unremedied bus and dealers will correct the hose connection, free of charge. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR3405.
Nova Bus is recalling certain model year 2004 and 2006-2013 LFS transit buses. Due to a programming error in the vehicle control unit, the ABS malfunction light may not illuminate if the ABS control unit loses power. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 121, "Air Brake Systems."
Safety risk
If the ABS malfunction light does not illuminate if the ABS control unit loses power, the driver would not be aware that the ABS is not functional and that the brakes may unexpectedly lock up under certain conditions when the brakes are applied, increasing the risk of crash.
Manufacturer remedy
Nova Bus will notify owners, and dealers will update the software for the instrument cluster, free of charge. The recall is expected to begin in late August 2014. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR3200.
NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 LFS TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Safety risk
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Manufacturer remedy
NOVA BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON FEBRUARY 26, 2010. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR NOVA BUS AT 1-450-472-6410.
NOVA BUS IS RECALLING 19 MY 2003-2006 LFS TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES WHICH WERE EQUIPPED WITH CM850 FUEL SYSTEMS. THE ENGINE HIGH PRESSURE FUEL LINES FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL ARE PRONE TO FAILURE. FAILURE TYPICALLY OCCURS AT OR UNDER THE FUEL LINE FITTING ATTACHMENTS.
Safety risk
THE INTRODUCTION OF HIGH PRESSURE ATOMIZED FUEL INTO THE ENGINE COMPARTMENT CREATES A RISK OF FIRE DUE TO POSSIBLE IGNITION WHEN THE FUEL VAPOR COMES IN CONTACT WITH HOT SURFACES.
Manufacturer remedy
DEALERS WILL INSPECT AND REPLACE THE NECESSARY FUEL LINE FITTINGS AND BRACKETS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2008. OWNERS MAY CONTACT NOVA BUS AT 1-450-472-6410.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.