Service brakes, air: supply: hoses, lines/piping, and fittings
Manufacturer
Nova Bus
Vehicles affected
5
Reported to NHTSA
2015-02-09
Owners notified
2015-04-10
Defect description
Nova Bus (Nova) is recalling certain model year 2009 LFS transit buses manufactured January 1, 2009, to December 31, 2009. In the affected buses, the brake hose fitting crimping ring may have been damaged and, as a result, the crimping ring may fail where the brake hose attaches to the air brake chamber.
Safety risk
Failure of the crimping rimgs may affect the braking performance, increasing the risk of a crash.
Manufacturer remedy
Nova has notified owners, and dealers inspected and replaced the damaged fittings, as necessary, free of charge. Owners may contact Nova customer service at 1-450-472-6410. Nova's number for this recall is CR1430.
Nova Bus (Nova) is recalling certain model year 2007-2009 LFS transit buses manufactured January 1, 2007, to December 31, 2009. A power feed cable in the battery compartment may have been incorrectly routed and clipped. As a result, the battery cable may prematurely wear and short to ground.
Safety risk
A battery cable that shorts to ground increases the risk of a fire.
Manufacturer remedy
Nova notified owners, and dealers inspected the buses and correctly routed the battery power feed cable, as necessary, free of charge. Owners may contact Nova customer service at 1-450-472-6410. Nova's number for this recall is CR1332.
Nova Bus (Nova) is recalling certain model year 2009 LFS transit buses manufactured January 1, 2009, to December 31, 2009. The affected buses may have an incorrectly wired main power relay circuit, causing the circuit protection to be defeated.
Safety risk
If the incorrectly wired circuit short circuits, there would be an increased risk of a fire.
Manufacturer remedy
Nova notified owners, and dealers corrected the main power relay circuit wiring, free of charge. Owners may contact Nova customer service at 1-450-472-6410. Nova's number for this recall is CR1366.
Nova Bus (Nova) is recalling certain model year 2009-2010 LFS transit buses manufactured January 1, 2009, to December 31, 2010 with ZFAV132 rear axles. The affected vehicles may have been produced with rear axle half shafts that received an inadequate surface treatment which may result in axle shaft failure.
Safety risk
If the axle half shaft fails, the bus would be disabled, increasing the risk of a crash.
Manufacturer remedy
Nova has notified the affected owners, and all affected buses have been reapired, free of charge. Owners may contact Nova customer service at 1-450-472-6410. Nova's number for this recall is BS1555.
Nova Bus is recalling certain model year 2004 and 2006-2013 LFS transit buses. Due to a programming error in the vehicle control unit, the ABS malfunction light may not illuminate if the ABS control unit loses power. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 121, "Air Brake Systems."
Safety risk
If the ABS malfunction light does not illuminate if the ABS control unit loses power, the driver would not be aware that the ABS is not functional and that the brakes may unexpectedly lock up under certain conditions when the brakes are applied, increasing the risk of crash.
Manufacturer remedy
Nova Bus will notify owners, and dealers will update the software for the instrument cluster, free of charge. The recall is expected to begin in late August 2014. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR3200.
Nova Bus is recalling certain 2009-2012 model year LFS and LFS HEV transit buses equipped with Sure Power DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Safety risk
Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Manufacturer remedy
Nova Bus will notify owners and dealers will inspect and replace the converters, as necessary, free of charge. The recall is expected to begin in January 2014. Owners may contact Nova Bus at 1-450-472-6410. Nova Bus's numbers for this recall are CR3030, CR3031, CR3032, CR3033 and CR3034 (depending on the converter's part number and location of in the vehicle).
NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 LFS 40 FT AND LFS 60 FT TRANSIT BUSES MANUFACTURED FROM MARCH 31, 2009, THROUGH FEBRUARY 11, 2011. AN INSUFFICIENT TORQUE WAS APPLIED TO THE DRAG LINK ATTACHMENT BOLTS DURING PRODUCTION. THE DRAG LINK COULD BECOME DETACHED FROM THE STEERING LINKAGE, CAUSING A LOSS OF VEHICLE CONTROL.
Safety risk
LOSS OF VEHICLE CONTROL COULD RESULT IN A CRASH.
Manufacturer remedy
DEALERS WILL PROVIDE OWNERS THE CORRECT DOCUMENTATION TO VERIFY THE TORQUE VALUES FOR THE DRAG LINK AND TO CORRECT THE DRAG LINK IF NECESSARY. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE CORRECT TORQUE VALUE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 16, 2011. OWNERS MAY CONTACT NOVA BUS AT 1-450-472-6410.
Service brakes, hydraulic: antilock/traction control/electronic limited slip: wheel speed sensor/tone ring
Manufacturer
NOVA BUS INCORPORATED
Vehicles affected
139
Reported to NHTSA
2010-07-12
Owners notified
2010-07-22
Defect description
NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2007-2010 TRANSIT BUSES EQUIPPED WITH ATC (AUTOMATIC TRACTION CONTROL) SYSTEM AND V-BEA MULTIPLEXING SYSTEM MANUFACTURED FROM APRIL 2, 2007 THROUGH JUNE 30, 2010. THE ATC SYSTEM MAY INADVERTENTLY ACTIVATE WHENEVER THE PARKING BRAKE OR THE BRAKE INTERLOCK IS APPLIED, SINCE THE VEHICLE'S MULTIPLEX PROGRAM DID NOT CORRECTLY SEND THE PARKING BRAKE OR INTERLOCK SIGNAL TO THE ATC SYSTEM. THE ATC SYSTEM COULD MISINTERPRET THIS SITUATION AS WHEEL SPIN, SUBSEQUENTLY APPLYING AND RELEASING THE APPLIED BRAKES. THE VEHICLE COULD THEN MOVE UNEXPECTEDLY.
Safety risk
THE VEHICLE MAY MOVE INADVERTENTLY EVEN WHEN THE PARKING BRAKE IS APPLIED INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REPROGRAM THE SYSTEM AND THE ENGINE'S ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 22, 2010. OWNERS MAY CONTACT NOVA BUS AT 450-472-6410.
NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2009-2010 NOVA LFS 40 FT AND MODEL YEAR 2010 NOVA LFS 60 FT T-DRIVE TRANSIT BUSES MANUFACTURED FROM AUGUST 27, 2007 THROUGH NOVEMBER 11, 2010, EQUIPPED WITH CUMMINS ISL OR ISB ENGINES. THE BOLTS ON THE ENGINE CRADLE WERE NOT TORQUED ACCORDING TO APPROPRIATE SPECIFICATIONS.
Safety risk
THE BOLTS CAN BE WORN PREMATURELY AND BREAK OFF, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
NOVA BUS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NOVA BUS AT 1-450-472-6410.
Engine and engine cooling: cooling system: radiator assembly
Manufacturer
NOVA BUS INCORPORATED
Vehicles affected
104
Reported to NHTSA
2010-04-06
Owners notified
2010-05-11
Defect description
NOVA BUS HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2007-2010 LFS BUSES EQUIPPED WITH MODINE ROOF MOUNTED RADIATOR. THE WRONG TYPE OF O-RING WAS INSTALLED AT THE LOCATIONS BY THE RADIATOR MANUFACTURER, MODINE. THE O-RINGS MUST BE VITON TYPE O-RINGS.
Safety risk
DETERIORATION OF THESE O-RINGS MAY OCCUR AND LEAKING OR SEEPAGE OF HYDRAULIC OIL.
Manufacturer remedy
DEALERS WILL INSTALL VITON O-RINGS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 11, 2010. OWNERS MAY CONTACT NOVA BUS AT 450-472-6410.
NOVA BUS IS RECALLING MODEL YEAR 2009 LFS BUSES EQUIPPED WITH Q'STRAINT MAX MOBILITY DEVICE REMOTE RELEASE BELTS USED ON AMERICAN INSIGHT TRANSVERSE FLIP UP SEATS WITH BUILD DATES BETWEEN OCTOBER 2008 AND OCTOBER 2009. THESE DEVICES ARE USED TO RESTRAIN PASSENGERS USING MOBILITY AID PRODUCTS. THE MOBILITY DEVICE RESTRAINT BELTS MAY NOT LOCK AS DESIGNED, AND MAY FAIL TO PROPERLY RESTRAIN THE PASSENGER AND THE MOBILITY DEVICE.
Safety risk
IF THE BELT DOES NOT LOCK AND THE MOBILITY DEVICE IS NOT PROPERLY RESTRAINED, THERE IS AN INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Manufacturer remedy
NOVA BUS IS WORKING WITH AMERICAN SEATING AND WILL REPLACE THE Q'STRAINT MAX REMOTE RELEASE BELTS WITH Q'STRAINT QRT DELUXE REMOTE RELEASE BELTS FREE OF CHARGE. AMERICAN SEATING IS HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE AMERICAN SEATING'S DEFECT REPORT 09E-065. THE SAFETY RECALL BEGAN ON DECEMBER 4, 2010. OWNERS MAY CONTACT AMERICAN SEATING'S SERVICE MANAGER SHERRY AELLEN AT 1-616-732-6484 AND NOVA BUS AT 1-450-472-6410.
NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 LFS TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Safety risk
A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
Manufacturer remedy
NOVA BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON FEBRUARY 26, 2010. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR NOVA BUS AT 1-450-472-6410.
Owner complaints
A complaint is one person's report to a federal agency. It is not a finding.
No complaints recorded for this model year.
Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.