Known Recalls

Model year record

2014 Toyota Sienna

6 recall campaigns on file for this model year. 226 owner complaints on file.

Recalls

Recall campaignNHTSA 19V553000

Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings

Component
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
Manufacturer
Vantage Mobility International, LLC
Vehicles affected
303
Reported to NHTSA
2019-07-25
Owners notified
2019-12-16

Defect description

Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.

Safety risk

The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.

Manufacturer remedy

Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.

Recall campaignNHTSA 19V410000

Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings

Component
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
Manufacturer
Braun Corporation
Vehicles affected
705
Reported to NHTSA
2019-06-04
Owners notified
2019-06-25

Defect description

Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.

Safety risk

The reduction in the braking system pressure may cause a loss of braking power in the rear braking system, increasing the risk of crash.

Manufacturer remedy

Braun has notified owners, and dealers will install an adaptor to correct the issue, free of charge. The recall began June 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.

Recall campaignNHTSA 19V005000

Air bags: frontal: passenger side: inflator module

Component
Air bags: frontal: passenger side: inflator module
Manufacturer
Toyota Motor Engineering & Manufacturing
Vehicles affected
1,299,448
Reported to NHTSA
2019-01-09
Owners notified
2019-02-15

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety risk

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.

Recall campaignNHTSA 16V858000

Structure: body: door

Component
Structure: body: door
Manufacturer
Toyota Motor Engineering & Manufacturing
Vehicles affected
744,437
Reported to NHTSA
2016-11-29
Owners notified
2017-07-28

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.

Safety risk

If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.

Manufacturer remedy

Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.

Recall campaignNHTSA 14V576000

Fuel system, gasoline: delivery: hoses, lines/piping, and fittings

Component
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
Manufacturer
Toyota Motor Engineering & Manufacturing
Vehicles affected
15,872
Reported to NHTSA
2014-09-19
Owners notified
2014-11-17

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 Toyota Avalon, Camry, Sienna, and Highlander and model year 2015 Lexus RX350 vehicles. Fuel may leak from the one of the fuel delivery pipes in the engine compartment.

Safety risk

A fuel leak in the presence of an ignition source increases the risk of a fire.

Manufacturer remedy

Toyota will notify owners, and dealers will replace any of the suspect fuel delivery pipes free of charge. The recall began November 17, 2014. Owners may contact Toyota customer service at 1-800-331-4331.

Recall campaignNHTSA 14V414000

Power train: automatic transmission: gear position indication (PRNDL)

Component
Power train: automatic transmission: gear position indication (PRNDL)
Manufacturer
Toyota Motor Engineering & Manufacturing
Vehicles affected
263
Reported to NHTSA
2014-07-08
Owners notified
2014-08-05

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 Sienna vehicles manufactured June 17, 2014, through June 24, 2014. The affected vehicles have a transmission shift control cable whose protective cable sleeve may have been damaged during assembly. This could cause the control cable to bind or separate during gear shift operation causing incorrect gear selection. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."

Safety risk

If the transmission shift cable separates while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Manufacturer remedy

Toyota will notify owners, and dealers will inspect and replace the transmission shift control cable, as necessary, free of charge. The recall began in early August 2014. Owners may contact Toyota customer service at 1-800-331-4331.

Owner complaints

A complaint is one person's report to a federal agency. It is not a finding.

ComponentComplaintsMedian mileage
Structure: body3658,000 mi
Unknown or other2750,400 mi
Air bags1414,000 mi
Electrical system1430,000 mi
Engine1446,000 mi
Fuel/propulsion system1432,430 mi
Vehicle speed control1178,929 mi
Service brakes1052,500 mi
Wheels935,000 mi
Power train760,000 mi
Steering752,500 mi
Structure: body: door740,886 mi
Suspension725,000 mi
Tires623,000 mi
Seat belts561,000 mi
Structure599,500 mi
Electrical system: instrument panel: speedometer/odometer4176,047 mi
Latches/locks/linkages4155,000 mi
Latches/locks/linkages: doors: latch4—
Electronic stability control (ESC)397,600 mi
Exterior lighting211 mi
Seats2500 mi
Visibility/wiper255,000 mi
Air bags: frontal: driver clockspring/spiral cassette162,500 mi
Electrical system: instrument cluster/panel11,600 mi
Equipment1—
Equipment adaptive/mobility18,000 mi
Forward collision avoidance: automatic emergency braking1—
Fuel system, gasoline11,800 mi
Lane departure: blind spot detection1—
Steering: column1125,000 mi
Traction control system194,000 mi
Vehicle speed control: accelerator pedal194,000 mi
Visibility: power window devices and controls17,700 mi
Visibility: sun/moon roof assembly140,000 mi

The 2013 model has roughly the same number of complaints as this one. The 2015 model has about half as many complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.

Open investigations

An investigation is not a recall. It indicates that NHTSA is currently evaluating an alleged defect but has not reached a final determination.

EA21002Desiccated Air Bag Inflator Rupture

Air bags: frontal: driver side: inflator module

Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.