Model year record

2001 Chevrolet Venture

9 recall campaigns on file for this model year. 284 owner complaints on file.

Recalls

Recall campaignNHTSA 07V349000

Fuel system, gasoline: storage

Component: Fuel system, gasoline: storage
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 20,594
Reported to NHTSA: 2007-08-08
Owners notified: 2007-12-04

Defect description

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Safety risk

A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Recall campaignNHTSA 04V597000

Latches/locks/linkages: doors: latch

Component: Latches/locks/linkages: doors: latch
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 717,302
Reported to NHTSA: 2004-12-22
Owners notified: 2005-05-31

Defect description

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Safety risk

IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Manufacturer remedy

DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Recall campaignNHTSA 03V250000

Equipment: other: owners/service/other manual

Component: Equipment: other: owners/service/other manual
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 1,707,825
Reported to NHTSA: 2003-07-15
Owners notified: 2003-08-20

Defect description

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Safety risk

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Recall campaignNHTSA 02V329000

Air bags: frontal

Component: Air bags: frontal
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 272
Reported to NHTSA: 2002-12-09
Owners notified: 2002-12-16

Defect description

ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.

Safety risk

THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.

Recall campaignNHTSA 01V383000

Seats: front assembly: recliner

Component: Seats: front assembly: recliner
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 75,816
Reported to NHTSA: 2001-12-13
Owners notified: 2002-04-10

Defect description

VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.

Safety risk

IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Recall campaignNHTSA 01V264000

Latches/locks/linkages: doors: latch

Component: Latches/locks/linkages: doors: latch
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 248,737
Reported to NHTSA: 2001-08-21
Owners notified: 2001-10-22

Defect description

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.

Safety risk

IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Recall campaignNHTSA 01V067000

Latches/locks/linkages: doors: latch

Component: Latches/locks/linkages: doors: latch
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 477,011
Reported to NHTSA: 2001-03-08
Owners notified: 2001-04-18

Defect description

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Safety risk

AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Manufacturer remedy

DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Recall campaignNHTSA 01V026000

Air bags: frontal

Component: Air bags: frontal
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 38
Reported to NHTSA: 2001-02-01
Owners notified: 2001-01-29

Defect description

VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.

Safety risk

IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.

Manufacturer remedy

DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.

Recall campaignNHTSA 00V228003

Seat belts

Component: Seat belts
Manufacturer: GENERAL MOTORS CORP.
Vehicles affected: 156,305
Reported to NHTSA: 2000-08-07
Owners notified: 2000-08-24

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety risk

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Manufacturer remedy

DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Owner complaints

A complaint is one person's report to a federal agency. It is not a finding.

Component	Complaints	Median mileage
Power train: automatic transmission	21	44,800 mi
Engine and engine cooling	14	41,900 mi
Structure: body: door	13	31,000 mi
Engine and engine cooling: cooling system	9	75,000 mi
Equipment: appliance: air conditioner	9	78,000 mi
Fuel system, gasoline	9	148,000 mi
Air bags: frontal	8	25,635 mi
Electrical system	8	22,531 mi
Engine and engine cooling: exhaust system: manifold/header/muffler/tail pipe	8	55,000 mi
Air bags	7	50,000 mi
Fuel/propulsion system	7	117,000 mi
Structure	7	35,000 mi
Unknown or other	6	26,640 mi
Exterior lighting: tail lights	5	56,900 mi
Latches/locks/linkages: doors: latch	5	26,000 mi
Visibility: windshield	5	46,000 mi
Electrical system: horn	4	30,000 mi
Engine and engine cooling: engine	4	47,300 mi
Equipment	4	38,000 mi
Exterior lighting	4	5,000 mi
Fuel system, other: storage: fuel gauge system	4	43,000 mi
Latches/locks/linkages	4	68,900 mi
Power train: automatic transmission: park/neutral start interlock switch	4	2 mi
Seat belts	4	65,000 mi
Service brakes, hydraulic	4	—
Service brakes, hydraulic: antilock/traction control/electronic limited slip	4	—
Child seat	3	—
Engine and engine cooling: engine: gasoline	3	—
Equipment: electrical: radio/tape deck/CD etc.	3	—
Power train	3	162,000 mi
Seat belts: rear/other	3	35,000 mi
Seats	3	—
Tires	3	32,000 mi
Vehicle speed control	3	266,000 mi
Visibility: windshield wiper/washer	3	65,000 mi
Electrical system: 12V/24V/48V battery	2	22,531 mi
Electrical system: wiring: interior/under dash	2	36,000 mi
Engine	2	112,156 mi
Engine and engine cooling: cooling system: radiator assembly	2	14,000 mi
Engine and engine cooling: exhaust system: emission control: gas recirculation valve (EGR valve)	2	16,042 mi
Exterior lighting: brake lights	2	85,350 mi
Exterior lighting: headlights	2	183,000 mi
Exterior lighting: turn signal	2	85,000 mi
Fuel system, gasoline: storage: tank assembly	2	—
Power train: automatic transmission: control module (TCM/PCM/TECM)	2	39,000 mi
Seat belts: front: anchorage	2	—
Service brakes, hydraulic: antilock/traction control/electronic limited slip: ABS warning light	2	22,531 mi
Steering: linkages: tie rod assembly	2	57,241 mi
Structure: body: door: hinge and attachments	2	35,966 mi
Tires: sidewall	2	59,963 mi
Visibility: power window devices and controls	2	—
Visibility: windshield wiper/washer: motor	2	—
Wheels	2	83,900 mi
Child seat: harness buckle: infant	1	—
Electrical system: instrument cluster/panel	1	78,913 mi
Electrical system: alternator/generator/regulator	1	—
Electrical system: ignition: module	1	—
Electrical system: starter assembly: relay	1	—
Electrical system: wiring	1	—
Electrical system: wiring: fuses and circuit breakers	1	—
Engine and engine cooling: cooling system: fan	1	80,000 mi
Engine and engine cooling: cooling system: hoses/lines/piping/fittings	1	34,000 mi
Engine and engine cooling: exhaust system: emission control	1	72,000 mi
Exterior lighting: turn signal: switch	1	85,000 mi
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings	1	—
Fuel system, gasoline: storage: tank assembly: filler pipe and cap	1	46,000 mi
Latches/locks/linkages: hood: latch	1	—
Power train: axle assembly	1	52,000 mi
Power train: axle assembly: axle shaft	1	44,800 mi
Power train: axle assembly: axle shaft: seal	1	—
Seat belts: front	1	55,800 mi
Seat belts: front: buckle assembly	1	43,000 mi
Seat belts: integrated child seat	1	—
Service brakes, air: antilock: wheel speed sensor	1	40,000 mi
Service brakes, hydraulic: foundation components: disc: rotor	1	—
Service brakes, hydraulic: foundation components: drum: wheel cylinders	1	35,000 mi
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings	1	83,000 mi
Service brakes, hydraulic: pedals and linkages	1	96,000 mi
Structure: body	1	170,000 mi
Structure: body: bumpers	1	—
Structure: frame and members	1	14,000 mi
Suspension: front	1	—
Suspension: front: hub	1	5 mi
Suspension: front: wheel bearing	1	5 mi
Trailer hitches: fifth wheel assembly	1	—
Unknown	1	41,100 mi
Visibility/wiper	1	15,000 mi
Visibility: defroster/defogger/hvac system	1	99,600 mi
Visibility: rear window wiper/washer: linkages	1	48,000 mi
Visibility: rear window wiper/washer: motor	1	40,000 mi
Visibility: rearview mirrors/devices	1	—
Visibility: windshield wiper/washer: linkages	1	59,850 mi
Visibility: windshield wiper/washer: switch/wiring	1	—

The 2000 model has about half as many complaints as this one. The 2002 model has roughly the same number of complaints as this one. These figures reflect raw complaint counts, not failure rates. Higher-selling model years naturally receive more complaints.

Safety recall repairs are provided free of charge by franchised dealers, regardless of vehicle age or mileage. This page displays aggregated data for the model year. To check recall status for a specific vehicle, search its VIN at nhtsa.gov.